So how much oil did you add? You said you have it down and it ends up perfect but you never stated how much you added.
@DamonG2017
3 жыл бұрын
“I always set my tire pressure to 20… obviously we have, nothing” sorry but this made me actually LOL!
@Kevinsgolfcarts
3 жыл бұрын
LOL glad you liked that.
@johnstutz4458
4 жыл бұрын
Hi Kevin, I have an EZ go that only wants to run with the choke on. What should I check? Thanks for your help.
@carieandree2259
4 жыл бұрын
We’ve been watching a lot of your videos trying to troubleshoot our problem. We have excessive gas gushing out through the air box. We’ve removed and cleaned the carburetor. When we close off both fuel lines it still gushes out. Not sure where the source of fuel is coming from. It will turn over...when it starts to fire gas begins shooting out. We’re at a loss...ideas?
@DannyArbuckle-kx5dt
2 ай бұрын
Cr😅
@DannyArbuckle-kx5dt
2 ай бұрын
Put a new cabarator on.
@walterschilling4512
3 жыл бұрын
Hello Kevin ,Great video, I have been going over a cart that I just picked up thats been sitting , I have 1 question about the rear fluid I was thinking about changing also , your thoughts,,,Thanks
@Kevinsgolfcarts
3 жыл бұрын
It wouldn't hurt to change it. It should be changed every 5 years with SAE 30 oil (if you have an EZGO).
@stevebirchmeier8082
5 жыл бұрын
Kevin, just found you site. You do excellent work and explanation of the repairs you do. My in laws have a 2001 txt that currently is turning over but will not start consistently. I have driven the cart quite a few times this year and notice I have had to use the choke at start up all the time even when hot. Now, if I pull the choke out fully it may start and run alittle but not long. I changed out the spark plugs. But have done nothing else. Any thoughts that you are willing to share I would much appreciate.
@Kevinsgolfcarts
5 жыл бұрын
Clean the carb. I'm willing to bet there is debris or water in the bowl.
@sergiocontreras8930
2 жыл бұрын
I have a 96 and seems to bogg down when step on fuel at full throttle, I cleaned the carburetor adjust valves and nothing helps
@sergiocontreras8930
2 жыл бұрын
Also the spark plugs looks very white like running lean but how do I check that
@armedfarm3429
3 ай бұрын
Awesome Video. How do you tell us so fast what year it is.?
@Kevinsgolfcarts
3 ай бұрын
The date code. The last 2 digits are the last 2 digits of the year.
@craigguinter8030
4 жыл бұрын
Were are the grease fittings at on the clutches on a Yamaha golf cart
@johnmichaud7643
6 жыл бұрын
Thanks - Great video- now I can change my old. Located here in central Maine.
@edwardsteel.023
7 жыл бұрын
I am currently working on an EZGO older model cart. I replaced the ramp buttons in the secondary clutch and all seems to be working in order, however i am having some issue's with the primary clutch engaging. Do I have to remove the engine to get the bolt that holds it in?
@Kevinsgolfcarts
7 жыл бұрын
You may have to remove a couple bolts on either side of the engine to allow the clutch to tilt up. This will make it much easier than fighting with it. You will also need a clutch puller in order to remove the clutch without damaging it.
@124bucket
2 жыл бұрын
how much oil does it take
@edwardsteel.023
7 жыл бұрын
AWESOME, I cant believe you replied so quick! Im heading to the shop now and do just that. Oh, I gave your vid a thumbs up.
@mindyjames2878
6 жыл бұрын
We just got new batteries. Tested them testes selinoid, checked Reed, lights come on but hold cart will not move. What can it be?
@Kevinsgolfcarts
6 жыл бұрын
Its possible you have a bad motor, controller, key switch, precharge resistor (if equipped). I would need more information like year, make, model, pack voltage. I'm assuming its a 96-08 EZGO TXT, 36 volt. If your cart is equipped with a Tow/Run switch, there is a sequence you can use to find the fault.
@macbirt56
2 жыл бұрын
You think like me with regards to the engineers who designed this stuff. My feeling is that they will never have to do any of the repairs so what do they care what is inconsistant with industry norms? I also think that someone in material control could have said, "Hey, we can save 5 cents per cart if we don't use red wire." lol
@mocasmotorsportsmedia5180
4 жыл бұрын
How many quarts of oil?
@sloppysecondsracing
5 жыл бұрын
I have a 1996 txt ezgo it smokes and I was told it might be cause I added to much oil. how much do u put in these? Any other ideas? I adjusted the valves new plugs every tried sea foam no luck.
@sloppysecondsracing
5 жыл бұрын
Oh the cart runs perfect that’s the weird part
@Kevinsgolfcarts
5 жыл бұрын
When and how badly is it smoking? Does it only smoke when you first start it and then it clears up? Does it smoke continuously while driving? First, check your oil level. If its overfilled, it will smoke and could cause seals and gaskets to blow. A few ounces over/under won't hurt anything. More than half a quart over could causes issues. Its possible the valve guide seals are leaking.
@sloppysecondsracing
5 жыл бұрын
It smokes continuously but when cold it’s bad as it warms up it’s just a bit.
@sloppysecondsracing
5 жыл бұрын
How hard it is and where can I get the valve guide seals.
@sloppysecondsracing
5 жыл бұрын
Forgot to mention I did a compression test and it was bang on forget the numbers and the cart is burred in snow at the moment
@hiddenacres4287
4 жыл бұрын
No compression check?
@edwardsteel.023
7 жыл бұрын
I love this video high quality filming and very informative. What kind of camera are you using?
@Kevinsgolfcarts
7 жыл бұрын
I mainly use a Panasonic GH4 and occasionally a Panasonic GH5 for these videos. Thanks!
@bchet4788
6 ай бұрын
Slow accelerating makes cart jerk. Fast accelerating is fine. Just slow.
@edwardvasquez218
3 жыл бұрын
I NEED U IN TEXAS. MY GOLF CART MECHANIC IS VERY VERY SLOW.
Пікірлер: 40