Dude, I'm two years late to this, but I had an evap leak. Couldn't trace it, tried smoke and everything. Change the purge valve and still had the issue. Lived with almost a year. Turns out, the purge valve I replaced the bad one with was defective.
@behunin1963
Жыл бұрын
Great vid. Some of the things you may consider are: 1. Set of cheap multi tester leads for applying power to a solenoid, just easier to control. 2. Q-tip 👍great for getting out the moisture great job. 3. Dielectric grease to lubricate the solenoid power connector, easy reseal. These are cheap and work miracles. Great job!
@leemaldonado6889
Жыл бұрын
Your videos are awesome! I'm a female who likes to do things by myself and work on my truck myself and I've learned so much from you and I've been able to fix my truck and get it to pass emissions thank you so much keep them coming cuz I'm still wanting to learn
@autoguydiy4244
Жыл бұрын
Well thank you very much. It inspirational to know we have some diy females on here.
@kevinshine885
Жыл бұрын
Hands down the best DIY mechanic on the net! Thanks!
@autoguydiy4244
Жыл бұрын
Thank you sir
@1windozesuk
2 ай бұрын
Firing off the parts cannon is not usually a good method, but I wouldn't say you fell victim to the gas cap. It is a cheap part, and I think it is worth it to try before digging deeper (time is money too). Also, on an older truck, the gas cap is probably towards the end of its life in regard to sealing. You did right trying the gas cap first, in my opinion. Another great video, ty
@markmartin3152
2 жыл бұрын
Jam up video. I get these codes when it seems that the weather starts changing. I too changed the cap that I actually have a few extra laying around. I now have another thing to check out next time it throws that code, excellent video. 2002 Dodge Ram 1500 4.7 3rd gen. My truck is great just has the piddly little issues the 3rd gen seems to have. I can usually look in dodge forums and figure it out, but your vid was straight forward and helped me out greatly on this reaccuring issue. ✌️
@autoguydiy4244
2 жыл бұрын
Thank you sir
@OutlawRR
2 жыл бұрын
Gotta be in Corpus with all that wind! Excellent to the point video brah. Thank you.
@autoguydiy4244
2 жыл бұрын
Your welcome
@williamcook3705
Жыл бұрын
Thank you for your videos. Thorough,Easy to understand . Spend the least amount of money. Keep living the dream.
@autoguydiy4244
Жыл бұрын
Thank you sir
@davidfalcon6061
2 жыл бұрын
Thanks for this video, I have the same truck model and year and following these steps fixed my problem. You also did a great job wording it out simple and clear down to the point...
@autoguydiy4244
2 жыл бұрын
Thank you sir
@quietsignal
2 жыл бұрын
More likely to be the nvldp natural vacuum leak detection pump. But the MOST likely is a cracked vent nipple on top of the fuel tank. The custom fix is a hinge roller pin to stabilize the broken nipple and covered with JB Weld, unless you buy a new fuel tank, if one even exists, $1200. Fuel tank from junkyard might work, but probably nipple is broke or about to break. The only real diag is to smoke the entire system and find the leak. For emission testing purposes you can fill the tank and clear the code and do a drive cycle. The evap code sensor is inoperative as long as the fuel tank is over approx 90% full. Also, on the federal IM test, you can have one module not ready to test as long as the mil isn't lit.
@OutlawRR
2 жыл бұрын
Absolutely a Great reply, gotta love the commitment from Dodge truck owners to other Dodge truck owners. I have a 3rd gen and a 5th gen... f'n tanks.
@quietsignal
2 жыл бұрын
@@OutlawRR Thanks, it took a lot of research. 2004 Dodge Ram 2wd 79k $3000 sound system😂 Wouldn't take $20k🤣🤣🤣
@TruthRISING2024
Жыл бұрын
I have a 2007 dodge Ram 1500. And that’s exactly what my problem is. Roll over valve on the tank. I’ve replaced the full pump, purge valve, gas cap, charcoal canister. After all that I figured that it must be the nipple that broke and I did my best to glue it in attempt to fix it but….. And yeah you can’t get it from dodge or OEM. Not the one I need. I’m thinking about going to a junk yard. Pulling a 35 gallon tank off of another dodge. I have the dreaded “gas cap”. Light on my dash. Driving me crazy
@johngalv9288
Ай бұрын
I've had this po456 forever...had diff. shops ck it, smoke it, nothing found! Now I delete the code before inspection and it passes. but it annoys me! and gas mileage is being affected I think. I replaced parts in the engine compartment. code still persists. I really like this 2003 Durango and plan to keep it. (185k miles) still strong!
@Berserkerwj2023
13 күн бұрын
Look at the intake manifold plenum seal. Look down into the throttle body to the bottom and if there is alot of oil pooled up that plenum seal is bad
@edzachary8657
3 ай бұрын
Wow great video bro I was having the same problem and I had no idea other than the gas cap. Thank you man
@GW-og4us
Жыл бұрын
Like the vid. I got a 04 dodge about 5 months ago and I just got that code. Just a fyi bud. Ok I'm a industrial machinery maintenance mech. Tech 42+ years. I Work on a lot of cnc grinding machines that have coolant running on them.Water does not effect dc voltage as in shorting like on AC. You can put lines on your + - battery and stick both into a bucket of water and nothing will happen and you wont get shocked. That's why vehicles and machines like grinding machines control components that are exposed to the grinding coolant are dc voltage. Water is not a good conductor of electricity. Especially with DC. but Will cause corrosion after a period of time. Again just a fyi. But thanks for the vid I'm changing my canister not that much money.👍
@autoguydiy4244
Жыл бұрын
Thank you very much. I really appreciate the information
@jameswoodard5735
8 ай бұрын
Nicely done
@user-ih6ss5qt2m
4 ай бұрын
Great video! Going strong, get 500,000 on that truck!
@user-fq4ij8ez7w
9 ай бұрын
got a Dodge Ram 2011 V-6, only 73,000 miles, so I got the P0456 Code, and I saw some videos, I decided that I would change the Evac Solenoid first, why? Because a lot of the videos have one thing in common, they changed out the Evac Pump first under the truck and the engine light came back on the dashboard. . I just took off the battery, and I un-screwed the bracket, and I took off the 2 hoses according to the videos that I had seen, and put the new one back on. I did buy a MOPAR Evac Solenoid because I really don't like to use after market parts, and its cheap about $35.00. Took about 15 minutes to put on, and answer the cell phone too. Been driving the truck now for about 3 days, so far No Engine Light, and if it does come on, then I will get under the truck to change the Evac Pump. No big deal. Was it necessary to take out the battery? For me, it was easier that way, gave me more room to work with. Take your time, be patient and you will be OK. Thank You.
@oneofgodschildren
6 ай бұрын
If it's not the purge valve try the charcoal canister above your fuel tank. If it rattles when removed it's bad.
@oneofgodschildren
6 ай бұрын
I just had this exact same code. New gas cap installed but there was surface rust on the opening that wasn't making a tight connection, cleaned it replaced the cap no more codes. 😂😂
@autoguydiy4244
6 ай бұрын
Sweet
@vincentsansevere7290
Жыл бұрын
Thanks for the video , well done & easy to follow
@autoguydiy4244
Жыл бұрын
Test it before you buy a new one
@marcharrington9457
Жыл бұрын
The OLD GLAZIERS SAY GO LAY SOME PIPE. Inside joke. Great Videos brother.
@autoguydiy4244
Жыл бұрын
Right on big dog
@user-ey5vc5of1n
4 ай бұрын
Thanks for the info!
@jessemoreno3471
Жыл бұрын
Thanks for your video, I got same problem.
@edwintapia310
Жыл бұрын
You are the man thanks 👍
@gimmesomesugar
Жыл бұрын
Very useful video! Thanks.
@autoguydiy4244
Жыл бұрын
Make sure to test it before you buy a new one
@ktdude1886
Жыл бұрын
Thanks bro!
@sclptrjoel
4 ай бұрын
saved mesome money! Thank you!
@marioantonio7639
Күн бұрын
Thank you
@badhabit7379
Жыл бұрын
You got lucky with a little moisture mine wasnt that issue
@johnathanc.1094
5 ай бұрын
Where do your lines hook up too I know one of them goes to the throttle body but where does the other line go to?
@autoguydiy4244
5 ай бұрын
The fuel tank
@vic21772
Жыл бұрын
Thanks brother gonna have to try it! I will let ya know!
@rgwilcken
10 ай бұрын
Bro, I had the same code on my 2011 ram 1500 5.7 hemi. Went to the smog check with the check engine light on. Didn't pass. Went home, disconnected the battery to erase the codes. Went back a week later. No check engine light, passed smog check. Didn't have to replace a thing.
@apmorales7187
Жыл бұрын
Good job amigo 👍
@GreenBeans-o9t
Ай бұрын
Was wondering if that would cause severe blowback coming out of oil fill cap? I'm getting ready to cut my catalytic converter off cause I had caught fir a couple times
@autoguydiy4244
Ай бұрын
You have either completely lost an valve seal or an oil ring on you piston
@GreenBeans-o9t
Ай бұрын
I inspected the cats and one i had a total hole through it so I cut out the other one and it was totally clogged so now I got em sealed shut I gotta wait to see if I can purchase new
@autoguydiy4244
Ай бұрын
@GreenBeans-o9t do you live an emission state
@squirttv69
7 ай бұрын
Same truck. I changed the leak detection pump and the engine light went off a month and today it came back on same code msising gas cap / small leak. Should i mess with it again or try this purge part first?
@rawfoodphilosophy7061
Жыл бұрын
You might have a leak in the purge valve. Why not blow threw it to see if it is slightly open?
@ipissed
Жыл бұрын
Just leave the top hose on and take the bottom hose off and feel the solenoid side you took the hose off for a vacuum. It shouldn't be pulling anything when it's at idle, and not purging. If it sucks your finger a bit you found the small leak.
@rawfoodphilosophy7061
Жыл бұрын
your idea is even quicker. When first starting a car, I guess the first 5 minutes or so purge should be closed? So then we can run your test, however, once the car is warm, the purge is open or partially opened?@@ipissed
@nancythompson2022
2 жыл бұрын
Awesome
@lamarsemallie5950
Жыл бұрын
What’s the part # for the hose’s?? Mine is broken and I can not find it at all
@autoguydiy4244
Жыл бұрын
Not sure let me see if I can find it for you big dog
@user-cc8xp8rv4c
Жыл бұрын
I have a 2004 dodge ram 1500 5.7 hemi , did your truck spit and putter? mine has 3 that say evap leak (very small), evap leak (small), and evaporative emission system, it doesn't spit and putter after half tank but if it goes a little below half it does that, was wondering if this is just a normal problem for these year rams? was thinking of taking it to a shop and having a smoke test done but don't know if I should just replace that part first and then go from there.
@autoguydiy4244
Жыл бұрын
No sir.
@cathedford
9 ай бұрын
Did you ever figure out what the problem was? My son has same vehicle, same problem. Thanks
@autoguydiy4244
9 ай бұрын
Tell him to check evap hose on the evap canister under the truck. If the evap system fail it will cause the truck to run bad.
@user-cc8xp8rv4c
9 ай бұрын
@@cathedford took it too a mechanic and they said the filler hose was not on all the way. hope this helps.
@jenniferblood4607
2 жыл бұрын
What did you end up doing to fix it? Mine just started doing this a few months ago. I clear the code and it stays off for about a month then comes back on. So I’m guessing not a fluke anymore.
@autoguydiy4244
2 жыл бұрын
I have not got around to it yet
@davidgibson2029
Жыл бұрын
So does anyone have a part number or link to the hoses that come off the vapor canister
@autoguydiy4244
Жыл бұрын
I do not buddy
@poomaster9578
Жыл бұрын
Have you found the part number I’m having trouble finding it my hoses burnt off
@lstruggy
Жыл бұрын
Dam bro sick 390K miles! Did u end up buying a new one cel come back? What’s the secret for having that much mileage? I just hit 211k miles on my Jeep GC! New sub!
@autoguydiy4244
Жыл бұрын
No sir I have 410,887 on it now
@lstruggy
Жыл бұрын
@@autoguydiy4244 have u changed the ESIM & your purge valve yet?
@autoguydiy4244
Жыл бұрын
@@lstruggy no sir
@samuelherman4859
Жыл бұрын
Bro Iam A Mopar all day I have 1996 4wd Dakota ext cab 3.9 L auto trans. I have 2004 Dakota 5 speed 4X4 also Magnum 3.9 L v6 and I bought am Ram 1500 2018 4x4
@samuelherman4859
Жыл бұрын
@@autoguydiy4244 and I don't know how the people say Dodge Ram ain't good 🤣🤣🤣
@markvietti
2 жыл бұрын
loose gas cap will cause that code too.
@autoguydiy4244
2 жыл бұрын
True statement but already went down that road same result
@andyhug3540
2 жыл бұрын
My truck 2005 dodge ram 15000 5.7 hemi threw 3 codes, P0440, P0113, P0441....I removed the filter and washed it with a high-pressure hose and allowed it to dry in the sun for a good 2 hours. I reconnected filter and all 3 codes disappeared. However, after 4 days without the check engine light being on, I performed a self-diagnostic and code P0585 showed, but the check engine light is not on. Shit is weird and frustrating. I love this damn truck and put a shit ton of money in it. Bro, your 2003 is close to 400K miles. Have you had to replace any major mechanicals? That mileage is very impressive. I currently have 136k. Had to replace transmission once (go figure) catalytic converters, all 4 o2 sensors, water pump, valve covers, etc...
@autoguydiy4244
2 жыл бұрын
I had to replace valve springs and differential. The rest is normal wear and tear items like water pump, wheel bearings. Brake pads, ect.
@villarrealmarta6103
11 ай бұрын
Is it safe to drive if that code is showing until it gets taken to a mechanic?
@autoguydiy4244
11 ай бұрын
Yes sir. It will not pass inspection until fixed. If you have an vehicle inspection
@villarrealmarta6103
11 ай бұрын
@@autoguydiy4244 ok thank you! I’m gonna subscribe. I have a appointment for it to get taken in a week from now. Just didn’t know if I can drive it to work and back until then.
@autoguydiy4244
11 ай бұрын
Yes sir
@villarrealmarta6103
11 ай бұрын
@@autoguydiy4244 thank you! Your channel is amazing and I hope you keep it going. God bless sir!
@amberb9885
2 жыл бұрын
What happened I'm having the same problem? Did it come back on?
@autoguydiy4244
2 жыл бұрын
It did come back on. As soon as my local auto part has one in stock I plan on buy a new one and replacing it.
@amberb9885
2 жыл бұрын
@@autoguydiy4244 I'm going to replace mine today myself due to the same problems. I'll see if it works. And let you know.
@kevindame2061
2 жыл бұрын
So did this work ?
@autoguydiy4244
2 жыл бұрын
I have not replaced mine yet sir.
@jacobsebastien3910
Жыл бұрын
@@autoguydiy4244 did a new one work?
@bamaman6959
9 ай бұрын
I had the same code on my 2017 got a new gas cap and the check engine light went off Replace the gasket first and replace that part
@autoguydiy4244
9 ай бұрын
You should have watched my video on the 4th Gen Ram, not the 3rd gen Ram.
@bamaman6959
9 ай бұрын
@@autoguydiy4244 I did I went ahead and changed both parts so I would not have to worry about it your videos were good and made it easy
@autoguydiy4244
9 ай бұрын
@bamaman6959 That's a big 10-4. Thank you for watching
@edwardcampbell3420
Жыл бұрын
Is that ohm reading for other years. I have an 07 that reads 15.5
@autoguydiy4244
Жыл бұрын
You should be good. Ss long as your not seeing some 40 olhm are something crazy like that
@edwardcampbell3420
Жыл бұрын
@@autoguydiy4244 thanx
@joshbullock7737
Жыл бұрын
Bro you know you can turn your key on and off 3 times to get codes without a scanner don't you?? the truck is it's own diagnostic tool for reading DTC's!
@autoguydiy4244
Жыл бұрын
Of course big dog.
@rais7450
Жыл бұрын
Are those seat covers? Very nice! Where can I get a set?
@autoguydiy4244
Жыл бұрын
Got them like that when I bought the truck
@paquesepas6696
7 ай бұрын
The click test is not 100% accurate at all once its in the car it could be intermittent
@EgCapalot
Жыл бұрын
Did you have bad fuel economy before u replaced it?
@autoguydiy4244
Жыл бұрын
I have alway had bad fuel economy with the hemi
@EgCapalot
Жыл бұрын
@@autoguydiy4244 I’m getting around 13 mpg in my Chrysler 300 with the 5.7 that’s unusually low
@autoguydiy4244
Жыл бұрын
How many miles are on it
@autoguydiy4244
Жыл бұрын
That actually sounds pretty normal to me
@EgCapalot
Жыл бұрын
@@autoguydiy4244 just hit 110k
@toddbob55
2 жыл бұрын
Bro go to the dealership for your parts please.....Those Aftermarket Autozone / Oreilly/ Napa/ Rock Auto all Garbage China parts that arnt worth the cardboard they are shipped in.
@Threefiftylegend
2 жыл бұрын
Hoe so if they keep going out on every truck made they use the same parts lol 🤣
@autoguydiy4244
2 жыл бұрын
Do you have a check engine light
@autoguydiy4244
2 жыл бұрын
Your welcome big dog
@badhabit7379
Жыл бұрын
NEWSFLASH for you , even the dealership parts come from China , japen etc
@mattbilbrey6131
Жыл бұрын
Dealership garage bs 😂😂🤷♂️ he’s trying to buy into the shit he’s been sold bless this man’s soul😂😂
Пікірлер: 136