Today I had a 2013 GMC Acadia in the shop with some transmission problems and I never thought this would be the issue even actually fix the problem. The customer said the "Transmission Hot Idle Engine" message came on after driving an hour on the highway. They pulled over and let the engine idle for 15 mins and the light went out but came back on after some more driving. They took it to a big box quick lube store and the service writer recommended a transmission flush because the fluid was dirty. They decided to come to our shop instead and I checked it out.
First thing I did was check the fluid level and then drove it around the block and noticed a slight shift flare from 2-3 and 3-4. pulled it back into the shop scan it with my Snapon Modis Scanner and found to codes in transmission or engine modules. I then went to data and logged the transmission information while driving on the highway about 15 miles. I noticed that the transmission fluid temp reached a temperature of 240 F and the engine coolant only reached ~205 F. The transmission cooler is built into the coolant radiator so the coolant has to cool the transmission fluid.
I was pretty sure the transmission was failing but wanted to make sure so I then checked the fluid again and notice some aeration of the fluid. I was think that the filter may be plugged causing the issue but decided to search the web and found a blog post about fluid level being too high causing the issue. I then checked the fluid again and noticed the fluid was actually over the full mark. This dipstick is very hard to read and even with dirty fluid I couldn't see that the fluid was several inches overfull. I found that if you use a paper towel and lay the dipstick down flat on the paper you can see how high the fluid level actually is.
So now we need to drain some fluid off and test it again. Since the customer wanted a flush I went ahead and performed the service and then used the drain on the machine to let the transmission line pressure push the fluid out. I drain a total of 4 quarts out of this transmission to get it at the proper level. It was probably 3.5 qts over but I has put about .5 qts of cleaner and conditioner in the fluid.
Now that the fluid was clean and at the correct level I drove the vehicle on the same route and at the same speed and the transmission fluid stayed at 200 F. WOW a 40 degree difference on a 20 minute test drive.
I think the fluid aeration was causing cooling inefficiency and the shift flares witch also builds more heat.
If you found this information helpful then please like the video and/or share it to you favorite GMC acadia forum.
This information also applies to any vehicle. Saturn Aura, Pontiac G6, GMC Acadia, Buick Enclave and LaCrosse, Cadillac SRX and the Chevrolet Equinox, Malibu, Traverse and Impala. and any vehicle with the 6T75 transmission are highly affected by the overfilled fluid.
Dex 6 fluid - amzn.to/2Ixt3GV
Fluid extractor - amzn.to/2NUAv4W
shop rags - amzn.to/2PG22V1
Gloves - amzn.to/2Ni7USL
The links above may be affiliate links that help support the channel at no additional cost to you. Thank you
Негізгі бет 2013 GMC Acadia Transmission Hot Idle Engine transmission overheat
Пікірлер: 54