Worked at a nuke plant that used two of these for emergency generators. They were kept heated and would start in an instant and slammed to 900 rpm and breaker would close in just a couple of seconds. Used air motors to start. The radiators had fan blades that looked like airplane propellers. The room would be nice and warm in the winter but would cool down to outside temp very fast when the radiator started pulling in cold air. The ship I was on in the Navy had 4 of the 16 cylinder versions of the 645 for emergency diesels. They sat right under our berthing compartment and made sleeping impossible if they were running.
@leadfoot1892
4 ай бұрын
To tell the truth this one must have been real cold because it took a long time to start. They don't need air motors. The exciter generator is used as starter motor on these until the engine fires.
@GreenRC24
2 ай бұрын
Very interesting!
@dougcook9282
4 ай бұрын
I worked at EMD when we started building Super Duties. The first one was so damn big when it came time to move it to paint. It would not go out the door. Made a lot of bosses mad and engineers. Plant manager finally told them to just knock the Damn wall down and get this Big Son of Bitch to paint. True story. I was there.
@3riversrambler
2 жыл бұрын
Sounds like both starter motors got a work out this morning
@SomeTechGuy666
4 ай бұрын
Air starters. They will run forever without over heating or burning out.
@leadfoot1892
Ай бұрын
These are not started with air motors. The Exciter generators are used as starter motors. I've worked on these for years and have the 645 technician certification.
@MCatSHF
2 жыл бұрын
Hello Dossett Yard Productions: A little bit of "body English" always helps!!! 0:19
@stevenschiffel4294
6 ай бұрын
Cold or not - AWSOME!!
@WhiskeyGulf71
26 күн бұрын
I want to see one of these EMD engined things staring up when the temp is below freezing ! Snow on the ground, “freeze your ass off cold” 🥶
@michaelnotigan7796
2 жыл бұрын
Phew, that was tough on the starter. Wondering if a Kim Hot Start (water jacket heater) is a viable alternative to aid in starting?
@choochoo742
2 жыл бұрын
It has/d a very cool diesel powered hotstart when we bought the locomotive and had it painted. Sadly whenever we disconnected the main battery’s to prevent NS from trying to start it in shipping it somehow created a low volt ground that fried and melted all the electrical for it. With as little as we use this thing with how big it is we haven’t really a need to spend the money to fix it or buy a new one.
@michaelnotigan7796
2 жыл бұрын
@@choochoo742 Thanks for that reply and info, I appreciate it. All the best!
@aaronbeaubien9324
2 жыл бұрын
A couple of volunteers and I swapped the starters on this unit back in 2017 when we were getting it ready for Santa Train. The old 32 volt starters melted the commutators into the engine room floor. These were some beefed up 32 volt starters that went on it to account for some hard cold starts.
@georgesam7805
4 ай бұрын
Kinda like my dump truck with a Detroit firing up in the cold. Starts every time
@danielhandler6646
2 жыл бұрын
CLAG!!
@garylarson6386
Жыл бұрын
I did a cold start on the c&nw rr at 10 deg needed a 16oz can of either in each air box, water drains were frozen but kept from free]zing
@pootispiker2866
8 ай бұрын
Ether in the airboxes causes explosions, try again.
@leadfoot1892
4 ай бұрын
I've started these in colder with no ether. The dump valves should have popped dumping the water.
Пікірлер: 20