Full Build Guide: / simple-diy-with-20207465
DIY Drawer-less Overlanding Drawer System for SUV from single sheet of Ply Wood:
Blog Post:
Subscribe:kzitem.info...
Trip Report Blog: allterrainfam.com/
Stickers and SWAG: allterrainfam.com/shop/
Instagram Profile: / allterrainfamily
Facebook Page: / allterrainfamily
#allterrainfamily #overlanding #suvcamping #suvdrawersystem
This is version 3 of an SUV Cargo Storage deck, and I think I’m done. For now…
The first version was a deck platform above the cooler. That worked fairly well when loaded, but for daily driving having the deck that high wasn’t convenient.
The second version was low, about 10.5 inches off the bottom. The cooler went on top as well as the dog and had room for more gear on top as well as underneath. With the low design, it was possible to have the dog sit on her pad on TOP of a couple Frontrunner Wolf boxes for a really efficient use of space.
V2 saw the addition of the slide out table for preparing snacks and lunch on the trail as well as full on cooking if necessary. The table proved to be a really good design in function, the only problem was the CONSTANT RATTLING when the deck wasn’t loaded with a heavy cooler.
You can get a full run-down of that build here: • 3rd Gen 4Runner Overla...
Now for V3 of the SUG Cargo Deck with Slide-Out Table. This one I made from 3/4 Sanded Pine Plywood and used the Kreg K5 Pocket Hole Jig for joinery. All the tools, materials and hardware is available at Home Depot.
The wood build is probably pretty close to the mass of the metal system, given that the metal I used was thin wall steel, however the wood table is a lot heavier. That said, it was a lot easier to built, didn’t require a welder and grinding.
I could probably make the wood deck a bit lighter by cutting out some portions of the sides, and I may do that at some point.
But this design works really well and the table is really functional and doesn’t make a sound at all going down the road.
Build List:
Everbilt 1-1/2 in. x 36 in. Aluminum Angle with 1/8 in. Thick: www.homedepot.com/p/Everbilt-...
Everbilt 3/4 in. x 4 ft. x 8 ft. Sanded Plywood (Actual: 0.703 in. x 48 in. x 96 in.) www.homedepot.com/p/3-4-in-x-...
Everbilt 9/16 in. Stainless Steel Rope Loop www.homedepot.com/p/Everbilt-...
Everbilt 1/2 in. x 6 in. Heavy Duty Beige Felt Strips (9-Pack) www.homedepot.com/p/Everbilt-...
Husky Light Duty Anchor Points (4-Pack) www.homedepot.com/p/Husky-Lig...
Howard BBC012 Butcher Block Conditioner, 12-Ounce amzn.to/2LqQaDT
Thompsons Water Seal 24111 1.2-Gallon Clear Low VOC Water Sealer for Exterior Use amzn.to/2LuFF2z
Tools:
Kreg Jig K5 Pocket-Hole System amzn.to/2LqwUGv
Kreg KHCRA Automaxx Right Angle Clamp amzn.to/2LvqtlF
Kreg SML-C125-500 1-1/4-Inch #8 Coarse Pocket Hole Screws with Washer-Head, 500-Pack amzn.to/2JAruXO
Gear:
WOLF PACK - BY FRONT RUNNER www.frontrunneroutfitters.com...
STRATCHITS - BY FRONT RUNNER www.frontrunneroutfitters.com...
Негізгі бет DIY Drawer less Drawer System for SUV from single sheet of Ply Wood for overlanding and camping
Пікірлер: 539