BMW should repair all SMG cars for free as it is a major recall defect they ignored for past decade.
@frankieharter9522
4 жыл бұрын
Your gear position sensor harness insulation is probably falling off & wires are touching. I’d pull the trans & re-rap all the wires individually & check previous work. I’ve never herd a smg pump prime that long & reach such a low rpm as if it was struggling. Good luck.
@macoh3115
3 жыл бұрын
I replaced the transmission with a used unit. I can only guess that the issue was the solenoid assembly that sits on top of the transmission which is silly money to replace, cheaper to buy a used SMG transmission
@philippk1125
3 жыл бұрын
well it also primes that long when you unlock the car and the battery is low
@benirving3807
4 жыл бұрын
Have you tried doing the shift mid point adaptions in ista?
@macoh3115
3 жыл бұрын
I replaced the transmission with a used unit. I can only guess that the issue was the solenoid assembly that sits on top of the transmission which is silly money to replace, cheaper to buy a used SMG transmission
@suhailmoola6157
Жыл бұрын
I have the exact same issue currently on my M5 E60, any update on how u resolved ?
@wiloskill
4 жыл бұрын
Did you test the accumulator pressure ? On my side, I've got the same noise, but the problem is due to first gear lock. Impossible for me to switch to another gear or on neutral... I tried pump pressure, it's ok, accumulator pressur, it's ok. I've got problem with solenoide clutch learn, i've got a message "exceeding the time allowed when finding the crossing of the valves'. Keep searching !
@wiloskill
4 жыл бұрын
I solved the issue with a good Directional-control valve for SMG transmission : 23017845630
@macoh3115
4 жыл бұрын
Here is what is interesting, when the pressure is on the higher side it works fine, but for whatever reason the pump either cannot keep up or something and once the pressure drops after a shift or two its stuck. I actually have another E60 M5 with a working SMG transmission. I am going to swap accumulators and see if that fixes it 1st
@macoh3115
4 жыл бұрын
@@wiloskill Is that in the accumulator?
@wiloskill
4 жыл бұрын
@@macoh3115 If the pressure is going down to fast, so the accumulator could be KO, if you have ista/rehingold, you can trying the pressure of the accumulator to check this one.
@salmaniftikhar6583
Жыл бұрын
@@macoh3115 bro the reason, you mentioned in the video , that you serviced everything , these units have extreme pressure , the who serviced it ,he destroyed the original solonoide valve seals behind the pump , only a new unit can solve it, or a highly trained staff
@mintech1000
Ай бұрын
Did you run bleeding procedure?
@GuitarsAndSynths
2 жыл бұрын
I had this shit happen to my M3 SMG car.
@mostafasaad6450
3 жыл бұрын
Please can help me Clutch (Activation position deviation) What’s that mean??
@The_North0
4 жыл бұрын
I think I have same problem as you do. I changed electric motor, pressure sensor and relay none of which fix the problem. The issue is that my hydraulic unit not able to build enough pressure. Have you find a fix?
@macoh3115
4 жыл бұрын
Not yet, haven't touched it since my post
@macoh3115
3 жыл бұрын
I replaced the transmission with a used unit. I can only guess that the issue was the solenoid assembly that sits on top of the transmission which is silly money to replace, cheaper to buy a used SMG transmission
@fuckjewtube69
4 жыл бұрын
Try pumping it up and doing the second gear change instead of first then second and see if that works. If it does then that pressure loss is not normal (and I don't think it should be) and you have a leak somewhere or through some seals internally. Do you still have the car? EDIT: Actually the pump was running during the second gear change so its gotta somehow be leaking somewhere when you're going into second. Try the rest of the gears hopefully its only on second gear maybe you can isolate the pressure loss.
@macoh3115
3 жыл бұрын
I replaced the transmission with a used unit. I can only guess that the issue was the solenoid assembly that sits on top of the transmission which is silly money to replace, cheaper to buy a used SMG transmission
@GuitarsAndSynths
2 жыл бұрын
@@macoh3115 or better swap to manual transmission to avoid garbage SMG!
@davescranes
4 жыл бұрын
Does that happen only in that specific gear or any gear after the first initiation.
@macoh3115
4 жыл бұрын
All gears, doesn't matter
@davescranes
4 жыл бұрын
Mine is getting fixed today as well. I have a complete spare trans and smg unit if you need anyparts
@macoh3115
4 жыл бұрын
@@davescranes What was yours doing and what was the fix?
@davescranes
4 жыл бұрын
So mine was working perfectly fine. But leaked from the slave, took it to a shop to have that replaced. The shopped messed up my gear selector harness and threw out some codes now replacing that harness and it says 1/r redundant so might do the actuators but im sure mine is just the harness. Just bought a complete smg unit from a guy who seems to only have pressure issues. What codes is that one throwing? Lets link it to a specific part and i can see if i have that spare part and could have it shipped to you. I got the trans as a spare from a paint job deal. The spare smg unit i paid 600$ came complete from a 75k mile car so it should be good
@BmwMe-uh9sy
11 ай бұрын
@@davescranesye mine says R-1 redundant also did u fix urs
@differentvibes8200
3 жыл бұрын
I have the same code on my m5 as well but it doesn’t grind and shifts perfectly fine. When I drive it hard then the transmission light comes on and wouldn’t move for a bit then drives fine I also have a code for the pressure sensor , could that be my issue ?
@dynamic2373
7 ай бұрын
Re adapt smg and bleed it
@tiagoestevao3593
4 жыл бұрын
Hello! Im having some problem with my smg After losing all the oil in the hidraulic system, it show a error Transmission preform adaptation Clutch :adaptation active In ispa it shows Hydraulic pressure too low And ajuste center position of shift range Im suspecting the pump is not building up enough pressure, can you advice? repair the pump?
@macoh3115
3 жыл бұрын
I replaced the transmission with a used unit. I can only guess that the issue was the solenoid assembly that sits on top of the transmission which is silly money to replace, cheaper to buy a used SMG transmission
@fouadchalal5657
4 жыл бұрын
Did you figure it out?
@macoh3115
4 жыл бұрын
Not yet, still getting some used parts together to test
@hassaantariq5937
4 жыл бұрын
Did you air the system out?
@macoh3115
4 жыл бұрын
Dd this multiple times, no change
@michaelmelton3644
3 жыл бұрын
@@macoh3115 This may be late but it's always welcome to me when I get some closure on this type of thing. The first red flag was the pressure drop. It's a sealed, pressurized system. Losing 5psi in seconds is excessive unless it's a relief setting, and you can check that by watching the pressure over a period of time. If it is a leak you're probably looking at the accumulator unless you can find an actual hydraulic leak in the lines or actuator. If it's none of those things the pump is likely the culprit. Ultimately it is the pumps job to keep up with system demands, the accumulator provides supplemental (reserve) pressure for operation when the pump isn't operating. This should help, or at least I hope it does. Good luck, SMG's are a patient mans project..
@tayibdprophete
4 ай бұрын
I think it needs to be bleed out, Proper scan tool and procedure
@atvdbrider5769
4 жыл бұрын
Sounds like grinding gears
@macoh3115
4 жыл бұрын
Oh yea? You think that is what it is?
@akshaygopaul6970
4 жыл бұрын
Hello ... Did the issue get fixed ?
@macoh3115
3 жыл бұрын
I replaced the transmission with a used unit. I can only guess that the issue was the solenoid assembly that sits on top of the transmission which is silly money to replace, cheaper to buy a used SMG transmission
@Linoge279
4 жыл бұрын
the smg pump need to be completely overhaul
@macoh3115
3 жыл бұрын
No, that wasn't it. I put a new pump on it and had the same issues. I replaced the transmission with a used unit. I can only guess that the issue was the solenoid assembly that sits on top of the transmission which is silly money to replace, cheaper to buy a used SMG transmission
@Linoge279
3 жыл бұрын
@@macoh3115 did you check the wiring harness? I had a friend who had the wiring harness insulation disintegrate and he had to replaced it because of that , these seem to be a common problem, worth checking out.
@macoh3115
3 жыл бұрын
@@Linoge279 to do the wiring correctly you have to remove the transmission, so I decided not to even try it. The wires were in rough shape
@Linoge279
3 жыл бұрын
@@macoh3115 sooner or later you need to fix it and surprisingly the clutch on these fast worn out even with low miles and the flywheel need to be change also.
@dmitrypravednov8518
2 жыл бұрын
When overhauled an SMG transmission you have to change all the solenoid on top even if you get a hole used transmission you need to change them
@chrismichael9045
3 жыл бұрын
issue resolved ?! what happened >?
@macoh3115
3 жыл бұрын
I replaced the transmission with a used unit. I can only guess that the issue was the solenoid assembly that sits on top of the transmission which is silly money to replace, cheaper to buy a used SMG transmission
@tropicalco2339
4 жыл бұрын
What happened?
@macoh3115
4 жыл бұрын
Don't know yet, still getting some used parts together to test it out
@macoh3115
3 жыл бұрын
I replaced the transmission with a used unit. I can only guess that the issue was the solenoid assembly that sits on top of the transmission which is silly money to replace, cheaper to buy a used SMG transmission
@mattman8569
3 жыл бұрын
1 year later and still no follow up response with the solution. What a joke channel this guy has.
@macoh3115
3 жыл бұрын
Because I never found the problem, I replaced the transmission with a used unit. I can only guess that the issue was the solenoid assembly that sits on top of the transmission which is silly money to replace, cheaper to buy a used SMG transmission
@AncientEvilSaiyan
6 ай бұрын
Very cheap to replace lol it’s the seals on the upper unit go bad lol 😂
@mkks8023
4 ай бұрын
It’s that $10,000 hydraulic unit captain obvious 😂😂😂…
@AncientEvilSaiyan
4 ай бұрын
you slow slow slow puppet, listen to me the whole smg unit never fails ! its the seals that go. i own 2 of these gems i know @@mkks8023
@GOGO-ex6rv
3 ай бұрын
my SMG doesn't go into reverse and immediately puts it in second gear, puts it back in first gear, but stays in second gear and the car won't drive.
Пікірлер: 61