This video picks up after having to pull the intake runners off due to a coolant leak (see previous videos if you are curious about all that, but Pro-Tip, "always use RTV sealant on water passages"). Once the lower intake runner is re-installed, the video progresses through final assembly involving re-filling the cooling system, priming the oil system and firing / timing the motor. Also shown is road testing where I seat the fresh piston rings by doing some hard pulls up a hill and WOT runs on the free way. Previous videos on the channel cover rebuilding this motor in greater detail, including ceramic coating the pistons, valves, chamber, etc. Hope you enjoy the video. Feel free to post in the comment section below if you have any specific questions about anything.
Following are links to stuff mentioned in the video:
--------------------------------------------------------------------------------
Impact of spark plug number of ground electrodes on engine stability:
www.sciencedir...
'Against the Ice' Trailer - good movie and captures what it's like to have your intake runner leaking coolant after almost being ready to start the motor:
• Against the Ice | Offi...
Bosch fuel injectors I'm running (also see my video about those on the channel):
www.fiveomotor...
Small Stainless steel bristle brushes I use to clean aluminum, etc:
www.mcmaster.c...
FEL-PRO MS 91679 Intake Manifold Gasket Set for 22RE motor:
www.amazon.com...
Permatex 82180 Ultra Black Maximum Oil Resistance RTV Silicone Gasket Maker:
www.amazon.com...
ARP Stainless Steel Studs 400-8023 (This is the kit I used to attach my intake runner to the LCE head):
www.amazon.com...
www.summitraci...
Socket drive caps / adapters - not exactly the ones I show in the video, but kinda close:
www.amazon.com...
DEPSTECH Triple Lens Borescope camera - awesome & inexpensive bore camera used in video:
www.amazon.com...
Denso (3031) W16EXR-U Traditional Spark Plug (stock heat range):
www.amazon.com...
Denso (3066) W20EXR-U Traditional Spark Plug (one step colder than stock heat range):
www.amazon.com...
Loctite 1835201 Green 680 Retaining Compound, 50 mL Bottle (use with primer # 7649):
www.amazon.com...
EPAuto Spill Proof Radiator Coolant Filling Funnel Kit:
www.amazon.com...
Zerex Asian Vehicle Red Asian Antifreeze/Coolant 1 GA:
www.amazon.com...
Негізгі бет ** FIRST START AFTER REBUILD ** 1990 Toyota Pickup w/ 22RE LCE head, ceramic pistons, cam timing
No video
Пікірлер: 19