I just finished this job, and here are some of comments that need to be mentioned if you attempt this. 1) The easiest way to remove the back-most bottom screw on the door panel is to get the door near the closed position to where you can fit a screwdriver on the screw head with the handle being inside the cabin; I found it quite easy to lay on my back (on the ground, not on the floor board) with the door almost closed to remove and install that screw. 2) Have the door closed about 3 quarters (3/4) of the way when trying to remove and install the door panel. 3) Do no lower the window when doing this job; leave the window in the fully up position. 4) It is not necessary to disconnect the cable going to the housing that the little motor is installed into; the housing can be opened with it attached. 5) I found it necessary to remove the gears from the housing that the little motor is installed into, otherwise I could not get the gear teeth to mesh up; maybe it can be done, but I couldn't figure it out. There is a spring loaded wedge assembly that holds a smaller gear to the lid of that assembly that I removed. I suggest you attempt to install without removing the gears and only remove if it just won't go together. 6) The window guide must be positioned in front of the cable that attaches to the outside part of the door (this requires that the actuator unit be positioned first (not bolted in, or even the studs inserted into the holes; just get it in the correct orientation), then the window guide second to where the cable loops around the right side (on a driver side door) of the guide (otherwise it would intrude on the path of the window when operated. The window guide will need to be mounted (not necessarily tightened down) first before mounting the actuator assembly. It took me about an hour to and hour and half to complete; it was my first time to do this job (hopefully the last time too).
@shdaggett1
11 жыл бұрын
Thanks mate! Dealer wanted $400 to fix this problem. Instead, I bought the part from them for $18.86 and did it myself. (I couldn't find the part any cheaper locally.) The video and the printed guide together are a perfect fit! BTW, it's a 2006 Kia Sedona with 123K miles and still going strong. Thanks so much for solving my problem!!!
@hannahgriller6969
9 жыл бұрын
YOU SAVED ME A FORTUNE!! I wasn't confident enough to remove the door on my own but I watched your video, ordered the part on ebay directly from Korea, then toook it to the shop where I had to pay for an hour of labour. I told the shop the problem but they kept saying it was something else ... I was right, they were wrong ... SO THANK YOU SO MUCH FOR POSTING YOUR VIDEO --- I am really grateful!
@mrdauntl3ss
8 жыл бұрын
how did he save you a fortune you just made him look bad I did it with the motor still on the door takes 30 min. guys if you follow his directions you will be set thanks for the video. good tip after you fix it turn the power switch off or you won't be able to get the panel back on
@cmac518
11 жыл бұрын
Just wanted to thank you again for your video. I replaced my passenger door latch motor this past weekend with your video assistance. I paid 14$ for the part from the nearby Kia dealership. I also used the TSB link on the forum to print out the pictures of each step. I noticed if you grabbed and held the handle (inside or out one) out very far (to the max) it allowed the door to unlatch manually and then seemed to be able to open/slide automatically. It was a good work around until I could get
@bluefish005
11 жыл бұрын
Excellent video - and THANK YOU for taking the time to post it. I have an '08 Sedona... and experienced the exact same problem. I purchased the actuator part for $14 from my dealer - after the maintenance supervisor told me that he suspected that it was a different problem. He was wrong. I followed the instructions - installed the new actuator - and voila! The door works great. It took me 1 hour - and I am not skilled at this stuff. For anyone wondering if you can do it... you can!
@jmadmac33
7 жыл бұрын
Gtd65! I just spent the morning doing this repair to my Kia. The fact that you had to troubleshoot at the end of the job gave me the confidence to keep at it after my first attempt failed. Great video! Thanks!
@gtd65
7 жыл бұрын
J Mac did you get it sorted in the end?
@jmadmac33
7 жыл бұрын
gtd65 sure did! Works great now.
@donwaterhouse3060
10 жыл бұрын
Hey gtd65, thanks very much for the walk through, everything went perfect. Kia wanted $470 to do fix, said it was the complete door mechanism. Saved $435 for a 45min fix. Thanks again.
@gtd65
10 жыл бұрын
You're very welcome!
@JaredHeelis
10 жыл бұрын
This is an exceptional video. Good people like you make the world a better place. Demonstrating the problems you had really helped me figure out the little (and important) things I bumped into. THANKS man!
@gtd65
10 жыл бұрын
You're very welcome - glad to be able to help out! :)
@QuadroNVS
5 жыл бұрын
well I am glad their is a video on how to fix this bit I still I wouldn't be confident playing around inside the door panel. I just paid the dealer a nice triple digit number to fix the same issue you fixed in this video.
@gtd65
5 жыл бұрын
I'm sorry I couldn't help you save some money on your repair bill but now you know how much you could save, you might want to give it a go next time? 😀
@luisrojas3315
10 жыл бұрын
Thank you for posting this video :) It guided me to fix the driver sliding door of my 2006 Kia Grand Carnival. The faulty motor was all rusted. Cheers from Australia
@ticosceninc.elsdexpertsfda7713
5 жыл бұрын
.Dealer thought my driver's side door was this problem: "the servo motor. " It was not. It was the logic controller instead of the latch controller shown in this video. So, FYI. Symptoms on mine was that it would OPEN with power but would not reverse and CLOSE with power. Hence, only problem was the closing under power not occuring. Door would respond but would continue to try to open and open and open. Never could figure out it was ALREADY open and needed to close. I did some forum reading and deduced that the fix may be to replace this module: 95450-4D102 Door (logic) Control Module. My door had been getting worse and worse in regards to not being responsive to the buttons and remotes. It was a gradual decline in function. This door "LOGIC" control module does require the dealer to program it into the system. But, i figured out which module needed to be replaced. The dealer was shocked and had no idea that module existed!!! It was a teamwork job between customer and dealer. Even the factory support folks were stumped. So, can't self fix it. But, YES, I did also replace the servo motor just to be safe while I was in there.
@gtd65
5 жыл бұрын
I can't say I'd heard of this either. Seems that most people get known problems with Korean vehicles. At least, that's how it's been for me with the cars I've owned.
@ticosceninc.elsdexpertsfda7713
5 жыл бұрын
Dealer master mechanic said in 14 years, he's never heard of or thought of this module being the culprit. I did read on another KZitem video thread that this could be the next module in line. It was correct! :)
@doesitmatter5301
Жыл бұрын
You have just confirmed I am not crazy. Thank you. I have the exact same problem and have been stumped and couldnt find anything about this and you explained it to a T of what my problem is. Now on the hunt for that module and i guess an appointment at my local dealerhsip,
@twopints67
10 жыл бұрын
Cheers for this video Gavin. I took my Kia Grand Carnival (as it's called here in Australia) and even though I told them about your video, they want to fleece me almost $1700 AUD to replace the whole motor assembly. I can get the part for $25 AUD and I'll just have to have crack at doing the job myself
@gtd65
10 жыл бұрын
Did you fix your Carnival in the end?
@iggyhouse
11 жыл бұрын
Thank you very much for posting this. I had the same instructions and found your video very helpful. Door now works on my Hyundai Entourage!
@djwell2
10 жыл бұрын
Thank you so much. Just did this on my 2009 kia sedona and it was the perfect fix. Only thing I would add is to pay close attention to the child lock. It wasn't mentioned in the instructions and mine got locked on reinstall. It took me an extra 30 minutes to figure out why it wouldn't open from the inside. Kia Part number is 81447-4D500
@gtd65
10 жыл бұрын
I can't say I noticed that problem when I did my install but thank you for the heads up :)
@ibdangler
11 жыл бұрын
Great post and very entertaining. I was laughing my ass off with the sticky goo on your fingers after the "dealer's handywork". Obviously your tropical environment didn't help. Anyways, off to fix my door on my van. Cheers!
@Cruiserspicoli
10 жыл бұрын
Great job on the video! My Sedona has been in the shop many times before for same issue and now that its out of warranty, I'm on my own. Thanks
@BrittneyDavis-ve4nm
Жыл бұрын
What about the cable on the left? Not the one that goes to the exterior handle, not the one that is “l-shaped” and has a pinkish/peach color snap in part, and not the ball shaped one with the white snap/clip. It’s the one that’s to the left of all of that. In a oval shape with a square bottom. There is a cable there. I think it somehow connects, or runs through the black piece with the two small, silver screws. But I can’t figure it out
@gtd65
Жыл бұрын
Brittney, is there a timestamp you can give? Been 10 years since I posted this one 😊
@BrittneyDavis-ve4nm
Жыл бұрын
I am so sorry 😢 I just can’t find the info anywhere lol but thank you so much for responding!! If you go to 5:51 the part on the left hand side. It is flipped over in this scene, but there is a metal rod that goes through it - and a small silver screw close to the piece in question
@gtd65
Жыл бұрын
@@BrittneyDavis-ve4nm I'm not really too sure. A good idea would be to go to the thread link in the description and the owners club site and post a picture. That's possibly the most practical advice I can give right now. Sorry..
@isaiaslivemusica8788
10 жыл бұрын
I have the same problem , I"ll try to fix it ,, good video my man !!!! thanks for your time ... before you fixed the door , did you try to rest it ??
@jr1274
11 жыл бұрын
this vid help I have a Hyundai entourage 2008 parts cost $12.95 and I did it in about 1HR .
@demcrackbrothers2
11 жыл бұрын
Hey this was a very help video it save me a lot of $ dealer want $ 200 part only cost $ 13.00 I did the work following the video thanks for this .
@themessagemix
Жыл бұрын
Thanks. I was able to do it myself thanks to your video! Where can you find the instructions you printed out?
@gtd65
Жыл бұрын
@themessagemix if you go to the description, you'll find a link to the thread at the Kia forums. You'll find the info there to download/print off.
@gtd65
11 жыл бұрын
You're welcome :) If the dealers just charged a fair rate they could make quite a bit of money really. Once a repair gets up in to the $100's it really makes a lot of sense to get the job done yourself. Of course all of the smaller dollar items can add up over time as well! There's a couple of KIA Sedonas on the KIA Owners sit,e with well over 200K and still running fine. It seems it's mainly smaller electrical gremlins that cause most of the problems - touch wood that is!!! ;-)
@gtd65
10 жыл бұрын
Yes, I tried to pull the shunt fuse and reset the doors but didn't help at all for me unfortunately. Luckily this is a very cheap repair if you have the ability to do the repairs.
@ticosceninc.elsdexpertsfda7713
5 жыл бұрын
My 2008 EX Sedona drivers side slider door opens under power just fine. However, it doesn't want to close. It beeps when you command it with the B pillar button or ceiling button. Remote control command responds too but it appears to keep trying to OPEN instead of releasing and reversing to close. Weird. I can close it manually and it locks open. When you showed the cable nub not being mounted after you replaced the motor, that is exactly how my door acts. You can open it under power and remotely. But, it doesn't accept any command to close. So, I think it's actuator related. Eh? Thoughts?
@markdavies5066
7 жыл бұрын
Thanks it helped on both doors only prob was that on one door it will not open and bleeps when shutting
@ShaneNottingham
6 жыл бұрын
2008 Kia Sedona EX worked great.
@toddspencer7255
10 жыл бұрын
Have you had to replace the power door drive cable on your van? The drive cable on the passenger slider just failed today, and I was wondering how difficult a fix it was going to be. Any advice would be helpful. Thanks.
@gtd65
10 жыл бұрын
Yes, see description
@gtd65
11 жыл бұрын
That's good - as long as you resolved the problem in the end that's the main thing :-)
@gtd65
11 жыл бұрын
Yeah it's probably an easy mistake to make, this will be a much less labour/labor intensive fix than the main door motor in the rear of the van. The upside is that it's a pretty cheap fix and it shouldn't take you that long to do - taking the video added time to the job but it's a good addition to the guide. Have you had any other problems with your Entourage?
@gtd65
11 жыл бұрын
There's quite a few common issues with these vehicles actually, which you don't notice or read about before you buy one.... Intermittent no start/no crank was the other problem - that surfaced not long after purchasing the van. Its now hopefully cured in my other video.
@avrock1874
10 жыл бұрын
Thanks for doing this as i have a similar problem although my door wont lock manually as well.The lock at the rear end of the door seems broken is this because of the actuator also?
@gtd65
10 жыл бұрын
I believe the actuator only starts the door opening, then the main door motor located in the rear of the van takes over.
@gtd65
10 жыл бұрын
Hope it all worked out for you in the end Jeremy :)
@gtd65
11 жыл бұрын
If you head on over to the kia-forums link at the top and join in you could post some photos of your door so we can check the differences. Have you downloaded the guide from the link in the address above. Remember this video really only supplements the guide that you can download and print out :-)
@gavfistow
10 жыл бұрын
This is my other account - yes I tried to pull the shunt fuse and reset the doors but didn't help at all for me.
@autumallen3127
10 жыл бұрын
I went to the link above to print the instruction guide for this fix. Can you offer further instruction on how to print the PDF? Thanks
@gtd65
10 жыл бұрын
Do you have a .pdf viewer like Adobe or CutePDF installed to view it? If not you'll need to download/install one of those programs. Once installed, then you just select print (assuming you have a printer).
@gtd65
10 жыл бұрын
Feels good doesn't it, when you get the problem resolved at a very low cost too? :)
@jepinney
11 жыл бұрын
Where did you find the guide?
@laurindabenner5116
10 жыл бұрын
Mine will only open and shut if I manually pull on it the whole way until shut or open....but it acts the same as this one did.....think it is the same issue?
@gtd65
10 жыл бұрын
I would suspect it's likely to be the same issue as it is a known fault with these vehicles. If you can do the work yourself, it's only going to cost around $14, which, will be much cheaper than a dealer or mechanic trying to troubleshoot the problem for you.
@isisda3
6 жыл бұрын
Hey!! I hace the same problem with my carnival's doors, so....could u send me the manual to fix the problem? Thank you so much!!!!
@gtd65
6 жыл бұрын
The information you need should be in the description above?
@Jaw3709
9 жыл бұрын
How did u remove the door panel can u give me details please my outer handle broke.off so.I'm going through door to replace it are those top two thin plastic trim pieces just snapped in or how are those removed thanks for your help
@gtd65
9 жыл бұрын
Did you not check the link with the guide in the KZitem description? You can download a .PDF file that has all of the instructions. It's the KIA Forums link.
@Sharon2426
8 жыл бұрын
I'm having the same problem can you come fix mines, I have 2006 Kia Sedona, It's been about 6 months, let me get this straight, if both doors have this problem then I would need two actuator ? your video was very helpfully where did you get your instructions from. Thanks
@gtd65
8 жыл бұрын
+Sharon Ford Click the link in the description of the video - takes you to the KIA Forums website and you'll see the information there. Just save the images and print off. If you are in Scotland I can pop round to give you a hand ;-)
@ivansalgado7622
10 жыл бұрын
I'm about to venture into doing this. Does anyone have a link to the instructions print out?
@jamescolpas
11 ай бұрын
THANK YOU
@gtd65
11 ай бұрын
You're very welcome James!
@gtd65
11 жыл бұрын
I've added a link in the video description at the top.
@kevinortiz4010
9 жыл бұрын
thanks for your video
@1215sabrina
10 жыл бұрын
?.. took my 2010 Sedona to dealer for latch upgrade. Door worked fine when I took it . Got it back and door is having the same issue you are showing. Any chance that they disconnected the actuator? Worked fine until the latch upgrade.
@gtd65
10 жыл бұрын
Is your van out of warranty already? If so, I'd try replacing the $14 actuator if you can't find any problems with the connections etc.
@BrianNguyen-jk5tu
10 жыл бұрын
Where did you print your walk-through from? I need to do this to my 08. Also do you remember the part no.?
@gtd65
10 жыл бұрын
The information you need is in the description for the video. I can't put web addresses in the messages (KZitem rules...)
@gtd65
10 жыл бұрын
Glad to be of help mate :)
@santiagoberrocal1848
10 жыл бұрын
Great video, very helpfull. Than you very much for making
@gtd65
10 жыл бұрын
You're welcome, glad to be of help :)
@jonm1013
10 жыл бұрын
My door is stuck open but I don't have power sliding doors. Is it the same fix?I noticed its stuck on the bottom too. Its an '08.
@gtd65
10 жыл бұрын
It won't be the actuator motor at fault for sure, if you have the manual sliding doors. I'd recommend heading over to the Kia-forums website to ask around for help - the link is in the description for the video.
@javierochoa432
5 жыл бұрын
Is there a way I can make my van power doors ??
@gtd65
5 жыл бұрын
I think if you had access to a van with all the parts it would be a pretty complex task. If you didn't, I don't think it would be very economical to do it.
@khalidmrgami4099
6 жыл бұрын
What should I do when the door stake
@gtd65
6 жыл бұрын
خالد مرقمي Can you open the door Manukau without power?
@clb52000
10 жыл бұрын
Checked power door fuse & actuator fuse. Both are in good condition
@Sharon2426
8 жыл бұрын
+Charlotte Louise Ludwig Baldassari Where are the power door fuses located at? thanks
@clb52000
8 жыл бұрын
+Sharon Ford This should show you clearly.... www.carcarekiosk.com/video/2010_Kia_Sedona_LX_3.8L_V6/fuse_interior/replace
@philhouse27
5 жыл бұрын
Long shot, but do you happen to have access to the guide anymore? It's a dead link.
@gtd65
5 жыл бұрын
I'll have a check when I get home later. Will get back to you
@gtd65
5 жыл бұрын
I've been on the site and it looks like they've "upgraded" something and completely messed up the formatting. I used Chrome and MS Edge but issues with both browsers. I can see the information but some of the Photobucket images are not displaying properly. I've tried to Login but clicking on the link takes me nowhere. This is the forum link www.kia-forums.com/threads/please-help-with-power-sliding-doors-2007-sedona.81215/
@philhouse27
5 жыл бұрын
@@gtd65 thanks for checking. There are some KZitem videos showing people taking apart the door. I'll have to try those. Printed step by step instructions would have been helpful. Thanks again!
@gtd65
4 жыл бұрын
@@philhouse27 seems to be back up now. www.kia-forums.com/threads/please-help-with-power-sliding-doors-2007-sedona.81215/post-447777
@gtd65
11 жыл бұрын
This is actually also a 2007 Hyundai Entourage as well :-)
@lusrodriguez8769
4 жыл бұрын
and the part is kia, wondering I have 07 entourage is it all the same
@gtd65
4 жыл бұрын
@@lusrodriguez8769 Yes, the Hyundai Entourage is actually built by Kia and just rebadged as far as I'm aware.
@lusrodriguez8769
4 жыл бұрын
@@gtd65 thank you for such quick reply and info
@sonorogrupomusical9776
10 жыл бұрын
thank you, I did it to my kia sedona. ;)
@gtd65
10 жыл бұрын
Well done! :-)
@abdumka
6 жыл бұрын
Do you have a link to that guide ? Pdf ? Thanks
@gavfistow
6 жыл бұрын
abdumka if you click on the link in the description above, it should take you to a forum that has all the information you are looking for.
@petermartintv
11 жыл бұрын
We have a 2008 Sedona and the N/S door went faulty last week. Found this video, ordered 2 motors (cos t'other one is bound to fail at some point) from sgpetchparts.co.uk, (£14 each inc p&p) fitted 1 this morning, door now working perfect. Very pleased with myself, but more so, eternally grateful to Mr Gtd65 for his help. So, job done and i'm now toasting your very good health with a rather splendid single malt from your 'neck o'the woods' Slainte Mhath!!
@gavfistow
10 жыл бұрын
The instructions are linked in the description,
@gtd65
10 жыл бұрын
Glad to be of help. :)
@MrUramos81
8 жыл бұрын
Where did you print your guides from?
@gtd65
8 жыл бұрын
+Uriel Ramos Click the link in the description of the video - takes you to the KIA Forums website and you'll see the information there. Just save the images and print off.
@gtd65
11 жыл бұрын
Glad to be of help :-)
@gtd65
11 жыл бұрын
You're welcome :)
@gtd65
11 жыл бұрын
'S e ur beatha ;-) No thit ah speak ony Gaelic like... ;-)
@scotchdrinker
10 жыл бұрын
Thanks gtd65 so much for the video. These instructions saved me a lot of money. I got the part for $17 on Ebay from the seller "kocarko". He shipped it from South Korea. Door Lock Actuator Motor MOBIS OEM Genuine Kia Sedona 2006-2014 814474D500
Пікірлер: 109