Link To Website: www.golfcartgarage.com/
Please click on the link below to schedule a call with Tim:
www.golfcartgarage.com/gearhe...
00:00 - ๐๐ป๐๐ฟ๐ผ
01:19 - ๐ค:๐ฌ๐ญ- Cart steering column issue - My friend has an electric cart that when you try to turn the steering wheel left, the tires donโt turn, but something feels like it is slipping or clicking. It turns to the right ok. Is the problem at the top of the steering column or somewhere down below?
02:46 - ๐ค:๐ฌ๐ฎ - ๐๐ฎ๐ฟ๐ ๐๐ฒ๐น๐น๐ผ๐ ๐ฏ๐ฎ๐๐๐ฒ๐ฟ๐ ๐น๐ถ๐ด๐ต๐ ๐ถ๐๐๐๐ฒ - Club Car 48v 2001. My Club Car will no longer climb inclines as it did just a few months ago. Before it would either go or at least spin trying. Now it will just completely stop and then a slight burning smell. Iโve load tested my batteries and the lowest reading was 7.52 on one of the 6 units.
04:44 - ๐ค:๐ฌ3 - ๐๐ฎ๐ฟ๐ ๐๐๐ฟ๐ด๐ฒ ๐ถ๐ป ๐๐ฝ๐ฒ๐ฒ๐ฑ ๐ถ๐๐๐๐ฒ - My batteries died completely over the winter. My charger started at 13 amps and is coming down, but after 48hrs still not dropping below 6
amps. The cart runs strong but wondering how long I should leave it charging if the amps don't drop further pretty soon.
05:50 - ๐ค:04 - ๐๐ฎ๐ฟ๐ ๐ฐ๐ต๐ฎ๐ฟ๐ด๐ฒ๐ฟ ๐ถ๐๐๐๐ฒ - I am rebuilding a 97 Club Car DS. I have replaced wiring with iq harness, mcor switch with upgrade solenoid with heavy-duty upgrade forward reverse switch to toggle switch and contactor, all battery and wires iq controller and motor. I just got it to run last night for the first time. It only runs for a few seconds and stops until I press the
accelerator again in forward and reverse. The new harness has connections for speed sensor, the new motor did not come with one. My old motor did not have one either.
07:31 - ๐ค:๐ฌ5 - ๐๐ฎ๐ฟ๐ ๐๐ฝ๐ฎ๐ฟ๐ธ ๐ฝ๐น๐๐ด ๐ถ๐๐๐๐ฒ - I have a 2013 EZGO golf cart that stops after driving only a short distance (perhaps 200yds). What could be the reason for this?
08:21 - ๐ค:๐ฌ6 - ๐๐ฎ๐ฟ๐ ๐ฐ๐น๐ถ๐ฐ๐ธ๐ถ๐ป๐ด ๐๐ผ๐๐ป๐ฑ ๐๐ต๐ฒ๐ป ๐ฒ๐ป๐ฎ๐ฏ๐น๐ถ๐ป๐ด ๐๐ต๐ฒ ๐ฟ๐ผ๐ฐ๐ธ๐ฒ๐ฟ ๐๐๐ถ๐๐ฐ๐ต ๐ถ๐๐๐๐ฒ - 2003.5 Club Car all original except batteries. Live on a hilly course, the cart has lost its git up and go. Where do I start? Trojan batteries on their 3rd season.
11:00 - ๐ค:๐ฌ7 - ๐๐ฎ๐ฟ๐ ๐๐๐ฎ๐๐ถ๐ป๐ด ๐ถ๐๐๐๐ฒ - My golf cart turns on and shows a full charge when hooked up to the charger but will not turn on when I take it off the charger.
12:02 - ๐ค:๐ฌ8 - ๐๐ฎ๐ฟ๐ ๐๐ฒ๐ฟ๐ ๐๐น๐๐ด๐ด๐ถ๐๐ต ๐๐ต๐ฒ๐ป ๐ด๐ผ๐ถ๐ป๐ด ๐๐ฝ ๐ต๐ถ๐น๐น๐ ๐ถ๐๐๐๐ฒ - My golf cart will not go forward, the battery is charged up. What could be wrong?
13:34 - ๐ค:๐ฌ9 - ๐๐ฎ๐ฟ๐ ๐ท๐ฒ๐ฟ๐ธ ๐ถ๐๐๐๐ฒ - Bought a Yamaha Drive 2 a year ago. When it was new it was quick off the line and ever quicker on the long run. Now itโs slow off the line and mediocre on the long run. What could be causing this change?
15:00 - ๐ค:10 - ๐ญ๐ต๐ต๐ณ ๐ง๐ซ๐ง ๐ฏ๐ฎ๐ฐ๐ธ๐ณ๐ถ๐ฟ๐ฒ๐ฑ ๐ถ๐๐๐๐ฒ - I have a 2000 EZGO TXT, 36V. Recently, the accelerator micro switch went bad. When replacing it, I also changed the Throttle Inducer and
the solenoid - 36V. All seemed to work well, and it was acting like new. While running at full throttle, it shut down and now will not move. I am at a loss where to start troubleshooting.
16:24 - ๐ค:11 - ๐๐ฎ๐ฟ๐ ๐๐ฝ๐ฒ๐ฒ๐ฑ ๐ฐ๐ผ๐ป๐๐ฟ๐ผ๐น๐น๐ฒ๐ฟ ๐ฟ๐ฒ๐ฐ๐ผ๐บ๐บ๐ฒ๐ป๐ฑ๐ฎ๐๐ถ๐ผ๐ป - I have a HuntVe vehicle which is built from a Club Car. A mechanic told me that Club Cars have a sleep mode if it has not been used for a while. Mine seems to be going to sleep mode very often and I need to know how to fix it.
17:50 - ๐ค:12 - ๐๐ฎ๐ฟ๐ ๐ต๐ฎ๐๐ถ๐ป๐ด ๐ถ๐๐๐๐ฒ๐ ๐ด๐ผ๐ถ๐ป๐ด ๐๐ฝ๐ต๐ถ๐น๐น - I have an EZGO ST 480 Workhorse, I replaced the throttle cable but the new one got red hot and broke, elec, short? Could this be the microswitch in the pedal?
24:04 - ๐ค:13 - - I bought the cart with 6 new Continental 2GC-8V batteries and an โupgradedโ Electrical Motor Products 3.8hp motor.
25:58 - ๐ค:14 - ๐๐ฎ๐ฟ๐ ๐๐ผ๐น๐ฒ๐ป๐ผ๐ถ๐ฑ ๐ฐ๐น๐ถ๐ฐ๐ธ๐ถ๐ป๐ด ๐ถ๐๐๐๐ฒ - 1986 ergo txt golf cart rear brakes the lever that the brake cable connects to is that supposed to be tight?
27:16 - ๐ค:15 - ๐๐ฎ๐ฟ๐ ๐๐ผ๐น๐ฒ๐ป๐ผ๐ถ๐ฑ ๐ฐ๐น๐ถ๐ฐ๐ธ๐ถ๐ป๐ด ๐ถ๐๐๐๐ฒ - I have the Madjax 6-inch lift kit installed. I have checked it 3 times and it's right but when I install the shock to the factor tabs it becomes 1.5
inches off from the Madjax a-arm mount and cant connect if. Does anyone else has this issue?
28:58 - ๐ค:16 - ๐๐ฎ๐ฟ๐ ๐๐ป๐น๐ผ๐ฐ๐ธ ๐๐ต๐ฒ๐ฒ๐น๐ ๐ถ๐๐๐๐ฒ - The red & the yellow light are on constantly on this Maintainer, Tender, Trickle Charger - 48 Volt. When does the green light come on? What's
the difference between the maintain & maintaining lights?
30:02 - ๐ค:17 - ๐๐ฎ๐ฟ๐ ๐๐ฎ๐๐ฒ๐ฟ๐ถ๐ป๐ด ๐๐๐๐๐ฒ๐บ ๐ถ๐๐๐๐ฒ - I have a Yamaha G19 and I put a 6 in lift on it and now the back frame sits at a steeper angle. Do you have something to correct this?
31:24 - ๐ค:18 - ๐๐ฎ๐ฟ๐ ๐ต๐ฒ๐ฎ๐๐-๐ฑ๐๐๐ ๐๐ฝ๐ฟ๐ถ๐ป๐ด ๐ถ๐๐๐๐ฒ - I have a 2008 DS Club Car installed 8.1 Nivel gears speed went from 22mph to 13mph gears are correct Graziano G style rear end. Would bad brushes cause problem? It ran perfectly before.
31:24 - ๐ค:19 - ๐๐ฎ๐ฟ๐ ๐ต๐ฒ๐ฎ๐๐-๐ฑ๐๐๐ ๐๐ฝ๐ฟ๐ถ๐ป๐ด ๐ถ๐๐๐๐ฒ - If I exceed 30 amps, is there a breaker that will trip? I am trying to limit the draw of a 100 amp starter to slow the speed of the starter.
32:48 - ๐๐ถ๐๐ฒ ๐พ๐๐ฒ๐๐๐ถ๐ผ๐ป๐
39:02 โ- ๐ข๐๐๐ฟ๐ผ
Thanks for stopping by the garage!
ะะตะณัะทะณั ะฑะตั ะะฒัะพะบำฉะปัะบัะตั ะผะตะฝ ะบำฉะปัะบ าาฑัะฐะปะดะฐัั Tips & Tricks for Golf Cart by Expert - LIVE Q&A | Golf Cart Garage I Episode # 32
ะัะบััะปะตั: 2