Thank you so much for this video! I ordered a replacement capacitor and switch for my system and installed them both. I am now back up and running after just $26. My motor also has that heat scorching mark. That’ll be next. I am now a subscriber to your channel because of the service you provide. Thank you!
@thinkertoo2995
5 жыл бұрын
I appreciate you making this video. My contactor and my capacitor BOTH failed this week. The A/C is 7 years old. Right on time. It was an easy repair. Thank you for the video.
@chrisjarvis1962
5 жыл бұрын
Very good tutorial of 3 easy things to check for a person with very little HVAC knowledge. Now you make me want to learn more about it. Thank you.
@SP-rp2qw
6 жыл бұрын
Ok, I've commented on many videos from noisy units to bad capacitors. With right at 40yrs experience in this field, let me add a few pointers folks. 1) the dual RUN capacitor is NOT a booster for the compressor or fan motor. They do store power and are for balancing out the power to each motor to keep them running. IF the compressor needs boosting to get started, it is done with a starting capacitor and starting relay ( or 2 wire start kit). The fractional HP fan motor will never need a booster. 2) the contactor relay will be in ALL CONDENSERS. Now if its a mini split ductless type system, then you may have a circuit board to operate the compressor. The standard single, 2 pole or even 3 pole contactor is magnetically operated. When control power 24 ( 120 or even 240 volts will be commercial systems) is applied to the coil connections, the coil becomes an electro magnet and thus pulls in the contacts to make connections from the LINE SIDE of the relay to the LOAD SIDE and the unit starts up and runs. If the unit does not start then you search for a break in the control circuit from either a re settable high pressure switch ( low pressure will never be a reset type) or possibly a timer ( some units have a time delay device) or a simple break in the thermostat wires near the condensing unit, possible cut by mowing or animal chewing through them. 3) Many condensers have the fan motor mounted shaft UP, and there should be a plastic disc pushed down the shaft to the body casing and sealant applied around the shaft to keep water from running down the shaft and into the motor. 4) many times a malfunction will be caused by a wire connection burned off at a terminal, caused by a loose connection at the point. Someone on here asked what each type of repair will cost, that all depends on where you live and the honesty of the mechanic to charge fairly on the parts markup and the prevailing labor per hour for your area.
@Straight_White_Fatherly_Figure
6 жыл бұрын
Doggy-style1994 dual start cap? What? Lol the fan motor doesnt even need a start cap and the box CLEARLY says run cap.
@billyuba2900
5 жыл бұрын
Thank you 🙏 man, for clarifying the details, I’m sure now, thermostat from up on my roof(just the wiring on a circuit board is only reading 15.3 volts so there is an electrical problem somewhere🤔but where now is the issue
@somap8380
2 жыл бұрын
Simple and best explanation. Thank you.
@NMranchhand
6 жыл бұрын
Say, that was a good, clear starting orientation. I especially liked the analysis of the “rust spot”;very clever. Thank you very much.
@fredhoffman6658
5 жыл бұрын
Wow. Pure info and no fluff. Thanks so much.
@Hugo_Furst
4 жыл бұрын
Another issue is ants or cockroach get in the contactor and prevents the contactor from connecting. I've had this happen many times and spent $$$ to find out an insect was the problem. If you install a new contactor by a service or yourself, make sure it is an "enclosed" contactor so bugs can't get in. It is a DIY project 30 minutes.
@mikeholland1309
2 жыл бұрын
Very informative, essay to understand video!! Thanks.
@cecilcollins3814
6 жыл бұрын
Good place to begin troubleshooting. Explained very well!
@dakellymon
3 жыл бұрын
Great video. I replaced the condenser, bit still would not run. I don't mind as it was 7 years since I replaced it. I went to step 2 and found an earwig smashed under the contact point. problem solved, Your video helped. P.S. I was surprised to find there was still electricity at the contacts after pulling the disconnect out.
@khaleeljabri4604
5 жыл бұрын
Very useful video & short ,, I had issue 2 was burned contactor. Thanks..
@cfergyman
3 жыл бұрын
Also the electrical switch sometimes gets a bug fried between the contacts , and won’t work. I just fixed mine with that exact problem🙂
@MiguelOrtiz-td7dr
5 жыл бұрын
Thank you for this information easy to understand to the point.
@gilvelez4840
5 жыл бұрын
u sir are a god for the homeowner!. Perfect and thanks for sharing!
@yononable
4 жыл бұрын
thanks..that is straightforward approach.
@gmlasam
6 жыл бұрын
Great and well explained video. Would you break down on estimate on how much each of the three common problems would cost to repair?
@nasiramgat827
4 жыл бұрын
Very clear explanation thank you sir !!!
@blackhorse2947
2 жыл бұрын
Good information………THX
@the1sgjohns
3 жыл бұрын
Thank you for the video
@kenstoner6355
5 жыл бұрын
Super helpful! Thank you!
@MrRUKidddingMe
6 жыл бұрын
granted, a lot of 'simple' preventative maintenance you can do yourself... clean out leaves, change filters and keep the units clean and clear... but when it comes to working on 240 volts and high voltage capacitors it's probably best to leave that to trained pros... if you get bit you'll remember it for the rest of your (possibly shortened) life
@frankgallegos5802
4 жыл бұрын
Always use the disconnect lever and use a multimeter to see if the power is off, it’s that easy.. be confident..
@shaifurrahman2536
6 жыл бұрын
Very good explained👍🏼
@OHUQTU
4 жыл бұрын
well done video
@jeffsilver4730
4 жыл бұрын
Excellent information, well done. Thanks.
@frankie2234
6 жыл бұрын
My problem, 2 seasons in a row, is the low voltage wires became loose in the wire nut and caused the 220 volt circuit breaker to shut off. Retaping and going to a smaller wire nut to make it tighter solved my problem.
@NoorRefrigerationsystem
4 жыл бұрын
Thank you sir I love this channel ❤❤❤❤❤❤
@BigDaddy-vh5jv
5 жыл бұрын
I hate when’s ants get inside the contactors I removed them cleaned the contactors and restored power to unit ant spray around the unit helped I purchased the contactors with the small cover that sits on top and those bastards still get inside warning mulch makes it worse ants thrive in the mulch and make a new home in the contactors
@JasonSmith-qx3zh
5 жыл бұрын
Excellent vid thanks big guy!
@rbuntin49
3 жыл бұрын
Just want to know how to stop hissing in the house. IT'S DRIVING ME CRAZY !!!
@pooplhiggs6744
6 жыл бұрын
"these typically last 5-7 years of good reliable life, after that they start to fail" Just like me!
@Power.of.the.Gospel
3 жыл бұрын
Very informative 👍🏼
@suhailasaba1051
4 жыл бұрын
Great video Question: I have a 1.5ton 220volts split unit AC. After few seconds of turning it on the, the clamp meter reads 22A then rise to reach 37A for few seconds then it stops and the clamp meter reads zero or 0.1A. What could be the problem ?
@realityhappens4893
4 жыл бұрын
Helpful video thanks
@ammartm1
4 жыл бұрын
I have brand new unit less than a year old my ac goes off every few days and kicks back on after 3,4 hrs later where should I start looking thanks
@brianturner9657
5 жыл бұрын
Great information. Thank you
@tomwarda2697
6 жыл бұрын
Have you ever used Cold Plus as a cooling enhancer? I have heard stories of saving 8% to 18% on both commercial and residential systems?
@cecilall4150
4 жыл бұрын
Outstanding!😊
@Nathan_Rave
6 жыл бұрын
Thanks. This saved me.
@jimmmorrison8373
6 жыл бұрын
verygood thanks Sr.
@mariobryant8803
4 жыл бұрын
This video- amazing
@yinghu8877
6 жыл бұрын
thank you sir!
@jimcalder4592
5 жыл бұрын
I have 240 going to the contactor but nothing out the top and switch is not going in
@blakehollingsworth839
5 жыл бұрын
Check your coil on the back of the contactor to see if your getting 24 volts from the thermostat.
@faustosalcedo7873
5 жыл бұрын
👴😃👍thank for your information it very helpful
@TuanNguyentexas
6 жыл бұрын
Thank you.have a good day Sir.
@samsohrabi6473
5 жыл бұрын
Hello, the fan start as should be but after 15 min it stops working. I already replace the capacitor. thank you
@fredhoffman6658
5 жыл бұрын
Hey Sam, did you ever figure out the problem?
@samsohrabi6473
5 жыл бұрын
@@fredhoffman6658 hi fred. Yes the motor went bad and almost burst. I replace it with new one. Thank you
@fredhoffman6658
5 жыл бұрын
@@samsohrabi6473 Thanks buddy. Im learning a lot a little at a time.
@youngoboaria4770
6 жыл бұрын
Good video
@Squidbillies1000
6 жыл бұрын
Thank you.
@fredgomez8473
6 жыл бұрын
Eclipse aircontrol light intermittently on and off
@user-ht4yb6xg8t
5 жыл бұрын
hello when i turn off the conditioner the outdoor unit still working? why?
@greatestever5775
5 жыл бұрын
Probably the thermostat
@TheFinishingCompanyRichmond
6 жыл бұрын
good video
@rustywanner1699
5 жыл бұрын
Thanks for the video, fixed the ac problem and my nagging wife!
@pakistanlonglive8629
6 жыл бұрын
Nyc
@hamzamo95
6 жыл бұрын
Hi, my AC just stopped working! Indoor unit is blowing air but outside unit is silent. I went and pushed the contacter button down and wedged a tooth pick to keep it down and that is how I had it running cold again. Would that work or do I need to look else where? Please help!
@danielvasquez4210
6 жыл бұрын
When you say, outside unit is silent, you can't hear the compressor and the fan?
@fatguyonagrom9515
6 жыл бұрын
😂🤣😂🤣 Never heard of that one.
@fatguyonagrom9515
6 жыл бұрын
No matter what anyone tells you if your a.c. equipment starts freezing up just wedge a few more tooth picks in there and open up the service valve and pour in more antifreeze. I did the research and you're a genius!
@fatguyonagrom9515
6 жыл бұрын
Your problem may be in the capacitor though its hard to trouble shoot over the net. Turn off the power to the unit, and set thermostat to off. Then do a capacitor reset. Discharge the stored energy (Google it) then take the wire that's on Herm and put it on C or Com, same with the one on Fan, then restore power and switch on cool. Let it stay there for 48hrs. There won't be any a.c. but rest assured you'll save $10 For Doing-It-yourself and a $60 service call.
@fatguyonagrom9515
6 жыл бұрын
Seriously though. Check the drain pan under your air handler for water, the float switch might've triggered your problem. If not change the batteries in your thermostat. Some systems have the ones that use micro switching relays that run off AA or AAA Batteries
Пікірлер: 67