Just FYI, the fuse/relay for the cooling fan is under the fuse panel. You have to remove the four Torx screws, and the red battery terminal to lift this up. There's also two clips on the front side. It's marked FFM8.
@KERPWANGITANG
5 жыл бұрын
THANK YOU!!! Been looking at the diagrams and i wasn't sure if i had to remove the upper portion to get to the fan relay. i dont have any torx bits maybe ill try an allen key with a rubber band hahaha
@keithratcliff7896
4 жыл бұрын
you are a legend, thank you
@jtmafia2972
4 жыл бұрын
Where the fuse panel located
@desertrat75
3 жыл бұрын
@@jtmafia2972 Next to the RED battery terminal. I'm not near the car, but I'll get back to you when I am.
@hamzabsila8973
2 жыл бұрын
Hi thanks for the comment, i have the same probleme with this module but i have never found a solution neither the fan control module were i live could you please give us more details?
@donc6545
5 жыл бұрын
Hi Art. It could also be a faulty wire coming from the temp sensor. If the wires connection is bad it will send a signal to the ECU telling it that the car is hot (causing the fan to constantly run) when in fact its not. Check for brittle wires as well.
@yosmarirodriguez9391
3 жыл бұрын
Resultados de las elexiones de vnz
@drreason2927
4 жыл бұрын
It wasn't the greatest video... But it did answer my question and successfully diagnose my problem. Thanks!
@dionmorehead2911
2 жыл бұрын
Absolutely great video. This video helped me tremendously 👍🏻😁. Thank you. Now I need to replace the fan in my Volvo.
@incomingshell3268
3 жыл бұрын
Under those fuses, once you unbolt the fuse panel ....Is a full set of other fuses, one of which is for the Radiator Fan.......
@cowlumbus
6 жыл бұрын
Relay is not needed because the silver box is the module and has a relay in it. It's designed to fail in the "on" position as a car having a fan running on high 24/7 is safer then not running and overheating. Most fail in the 100% on (even with ignition off) and my solution was always to pull the battery cable...but I guess the ECM relay is an option too...that I wouldn't think would cause issues although. If you do have a failed ECM (unlikely) then your only option is to clone it as a new ECM an only come from Volvo and will set you back $2000 on a car that is prob only worth $2000!
@desertrat75
6 жыл бұрын
There is a fuse/relay, under the fuse panel, marked FFM8. You have to remove the top of the fuse panel, there's four Torx screws and the red battery terminal.
@andrewk.7498
2 жыл бұрын
I WISH my radiator fan ran nonstop. My stupid S80 would stop overheating
@KavoTheGodd
Жыл бұрын
Same
@SagarSagaya
2 жыл бұрын
thank you for the detailed explanation bro
@maritzagarcia1112
6 жыл бұрын
What is this part called, I’m having this issue and would like to purchase a new one
@andrewmullins5169
Жыл бұрын
Can you run a toggle switch to the signal wire?
@dnotme4900
2 жыл бұрын
If the fan wont turn on can i test it by connecting wires to battery to test ?
@dunkan42
6 жыл бұрын
That's exactly happen to my car S60 2003. I'd like to buy a new after market, because the origin part is too expensive, what do you think about it ? And you know what honestly I never found the relay. Any advice? I'll appreciate it
@orfeous
3 жыл бұрын
On idle with AC-on and temperature set to 16 degree celsius and with normal engine temperature my engine fan/ac-fan is turning on and off every second. Really annoying. Gearbox set to Neutral, handbrake on. ECC set to Auto. When i start to drive in city or outside the engine temperature falls to the line next to "middle" and also a little less. And when im parked again at idle the gauge is raising to normal temp in like 5min again. really annoying. Volvo S40 2006
@JesusChrist-pc1lx
8 ай бұрын
When the fan goes too fast the temp coil inside the module busted so yes the whole fan has to be replaced inless u kno some magic or aliens n can fix the coil...it no longer can guadge the temp so it blows the fuse inside n the fan looses control
@megalomaniacko1
3 жыл бұрын
In my case (XC70 2.5 AWD 2010) the little fan is not starting (and I cannot use the AC). When I stop the car in hot weather the big fan start functioning once the engine is off. It stops after 2-3 minutes. Starting the engine again starts the big fan depending on the temperature, then it stops. If the weather is cool the big fan does not start at the beginning, only from time to time, I guess when needed. The little one is always down, and sometimes I'm running the car without both fans. I'm thinking of replacing the whole piece. Shall I check another thing? My "mechanic" hasn't figured out and he's just pretty much charging me for resetting the fail in the computer. He did it twice and both fans worked including the AC. But after 2-3 days, again the AC was down, the little one is not working, and the big fan starts in hot weather and on cool weather starts just "when needed I guess". Help. Thanks!
@prudhviraj451
2 жыл бұрын
Hello Ed..have you found a solution to this?
@michaeljoeldouglascontrera7424
Жыл бұрын
estoy en las mismas con mi volvo xc70 d5 2011 un dolor de cabeza
@augerino
4 жыл бұрын
Show us how to replace it
@tomasgulas
8 жыл бұрын
any way to diagnose fan that does not run on?
@ArtStamos
8 жыл бұрын
Go to a parts store and get some jumper wires, they look like a wire with clips on both sides, connect the fan directly to the battery. I hope this helps. This may also not work since some fans have a 3rd signal wire and I belie that that one is not 12 volt, may not work because of that.
@andybauer9689
6 жыл бұрын
mine doesn't come on when I jump it, what do I do now??
@uRealReels
2 жыл бұрын
what signal can u send to the purple wire to run all the time?
@Daninater
Жыл бұрын
I think it's a square CAN signal or if it's missing a signal it usually runs all the time.
@raszamataz46
8 жыл бұрын
thanxs i have s40 t5 that fan will not turn off soon as battery is connected its on wont go off unless disconnect battery
@TheMichelleAmato
7 жыл бұрын
Is this a similar problem to the fan continually running while the car is running? When I take my key out the fan stops. The car is not over heating, I am thinking I have a bad signal wire.
@ArtStamos
7 жыл бұрын
it sound like I wouldn't worry about it since it stops running when the ignition is in the off position. The fan will turn on when the car gets hot enough or when you turn on the AC. Try it without ac and cold engine.
@TheMichelleAmato
7 жыл бұрын
The fan is starting up when the car starts and it is still cold, even after sitting overnight in Maine. The fan runs the entire time the car is running. The AC hasn't been on in years, something is malfunctioning. I am going to keep trying to find out what it is because eventually the fan will need replacement from running all the time. I don't want that to happen in the middle of a long trip. If we figure it out. I'll post the cure here. Thanks!
@ArtStamos
7 жыл бұрын
yes, that makes sense you need to replace the fan, there is a relay inside the fan that is stuck closed. If it ever becomes unstuck the fan will not turn on. It's not a serviceable. Keep the shroud just replace the fan inside. You can find a used one cheap on e-bay for like $50 make sure it has the same signal wire I have seen one version that did not.
@TheMichelleAmato
7 жыл бұрын
Thanks Art. I'll keep you updated!
@emilsvantesson85
7 жыл бұрын
have the exact same problem... standing in this moment in 20cm snow trying to figure this out! checking everything from fuses to contacts etc etc..... and yesterday i noticed, because the fan runs 100% from start to stop it is eating alot of power that effects everything when im driving ( cupe-fan, light, engine-idle "flickers" when i clutch... ) and now when the outdoor Temp whent to minus-C ( -C ) the engine never reaches "standard" Temp...... if i find the problem i will post as fast as possible! :) and if you get anywere with it please update me! :D good luck! ;)
@damianp7313
3 жыл бұрын
I spent hours researching this and came to the same conclusion I could of watching a 6 min video FML
@murraymadness4674
2 жыл бұрын
My big question is how to replace JUST the module, and not the whole fan. It just unbolts from the fan housing, but the two wires into the fan motor don't seem to disconnect. I could always cut and solder them back, but hope someone else figured it out. There does seem to be a bolt holding the top cover on the motor? If its undone will the cover come off and the wires can be removed easily?? Someone needs to make a video on how to do this, I can't find one.
@360escapades
Жыл бұрын
Did you ever find a video on the volvo fan control module,?
@insanebeatjunkie
6 ай бұрын
I was wonderin the same since i dont feel like takin a completley good fan out
@augerino
4 жыл бұрын
That’s the hard part
@BomaxGaming
7 жыл бұрын
i have a problem in my V40 T4 when ever i STOP the engiene the fan starts running?
@Bakuradzee
7 жыл бұрын
it's MAF sensor problem
@johnkillian5328
6 жыл бұрын
Problem.. cant get my fan out. Help!
@mieketelkamp1884
2 жыл бұрын
My volvo fan doesn't turn on........
@mikef6706
4 жыл бұрын
Are the fans in the S60 single or two speed?
@1stedfast
3 жыл бұрын
variable speed it is called pulse width modulation
@kayrams1792
11 ай бұрын
It's the fan module not the fan motor which is the problem. The Bosch fan module have a defective problem! Poor quality
@emilsvantesson85
7 жыл бұрын
OK!... SOLVED!! but with a BIG "?" mark!! gonna try make this easy and simple :) - my Fan was going 100% from start to stop... and i also had the "Check engine" lit up. the engine light has been going on and off from the begining and no problems or codes were found. but a month back my Fan started the 100% all the time thingy.... and i also had the "time for service" message. also have had some problems with the battery. i tried the DIY thing to reset the "time for service" message. after i was done i tried to start the car BUT the battery was dead!.... i got a new battery in and turned Ignition to step II. i had the "time for service" message back in the display and the "Check Engine" light. i left it there for about 10-20sec and then the "Check Engine" light started to blink around 5-8 times then it TURNED OFF!!! :D started the Engine (cold) and the Fan mas quiet!!! :D :D "Check Engine" light was OFF! did a test run, got the Engine to NORMAL temp and it stayed there as it chould. still no "rushing" Fan! All i did was DiY reset of the "time for service" and switched Battery! so if you have a healthy battery please try disconnect it for 5-10min and plug back in and see if it workes! and if not, try the reset, then battery unplug ;) and please leave a note how it whent! :) hope this is a "real" solution!.............. because it was FREE! :P
@dice513
5 жыл бұрын
your comment made my day and save my money. thanks a lot!
@monoseq9797
5 жыл бұрын
hope this works, i need to try it tomorrow after i tow it back from the middle of nowhere.@@dice513
@honorablewiz7447
2 жыл бұрын
probably switching the battery did it
@thomasbassett5475
29 күн бұрын
You fixed everything by installing a new battery in your car. Cars have become way more temperamental when they are not receiving the right amount of voltage which can sometimes start to make other things in your do wacky things. Such an easy fix that most people can do on their own but most people don't think it's their battery that is causing their problems because it still has some juice left in it and can start the car. That's why you should always check to see if your battery still has enough juice before you go and start replacing other parts that might still be good but are not working right due to your car battery simply not having enough power in it anymore to keep your cars electrical system working happily. It's a shame that most newer cars are now using so many more electrical parts and sensors that will guarantee fail early in the life of the car when they could have just kept those cars simple using nonelectrical parts that will last 5 times longer than the newer electrical parts will last. They say they did this to make cars better but I believe they did this to make cars fail quicker so that people will either have to buy a new car again or end up spending ridiculous amounts of money at the dealerships because they also made it so that you would need to have very expensive tools that many mechanics would need to basically pay a yearly subscription from the dealerships in order for anyone else to have the ability to fix these newer cars. That just hurts the consumer because they no longer can fix their cars with simple tools they could buy at Home Depot. Even independent mechanics will not be able to repair people's cars for a fair price now because they have to charge higher prices to be able to afford to pay for those yearly subscriptions which they would have to buy one subscription from every manufacturer in order to be able to fix all cars which would cost that shops hundreds of thousands of dollars every year them to do that. It's all by design so that the dealerships get paid no matter what because all newer cars are only built to last as long as they warranty that car now. The days of driving your car and maintaining it yourself are over unless you don't mind spending ridiculous amounts of money to keep that car on the road longer than 5 years. This is only happening because people in this country are all accepting this as the new practice. Sure people are mad about this, but not mad enough to fight back these criminals from continuing to do this to everyone. So this will only likely become much worse until the people start to fight back. And I'm not going to hold my breath waiting for that to happen in this country. People in this country have completely forgotten how to fight back and they forgot that this fight can never stop because the moment they do stop, you can guarantee that those criminals will immediately try to take advantage of that every time. I hear many people tell me that it's not their responsibility to have to fight back and then I ask them well who's is then if it's not their responsibility? They can never give me a name or show me that person who is supposed to be fighting for them. Some say it's the government but the criminals have already bought and paid for every single politician in this country. The people allowed that to happen here as well. So really it's the peoples responsibility to always be fighting back the criminals because criminals will never go away and you cant expect people to do your fighting for you all the time. That's just the way life is in this society. I just wonder how much more the people are going to give to the criminals now because these criminals are all around us now. There isn't one aspect of this society now that hasn't been completely corrupted which means it's just a matter of time before they will bleed everyone in this country of all of their wealth and eventually most people will no longer be able to afford the very basics just to survive anymore. Many people have already succumbed to that. Just look around at all of the homeless people there are now who were not there 10 years ago. Those people are not homeless now by choice or because of drugs. They have been bled dry with no way for them to survive here now. If they are doing drugs now it's because they have nothing left anymore and they have given up trying. Their numbers are growing steadily every day so you better expect to start seeing 4 or 5 times more homeless people than there are living in the streets today in the future because that is the path everyone is on right now because the people have stopped fighting back. It's not enough for people to just fight back their own problems. They should care about helping other people as well because it's very hard to fight back once you have gotten to the point of having only the clothes on your back. People right now think they are immune to that happening to them and they are very wrong about that because they are already on the path of becoming homeless themselves. They just don't want to believe it's possible yet till they start to realize how much money they have left and how much money it costs now for people to live in this country. It's completely out of control and you have Wall Street to blame for all of this. The rich in this country own practically everything and we are not talking about millions of people here. it's in the thousands for sure and these people only care about one thing. Making more money. They won't stop till they have it all. It's like a disease with these rich bastards. They have already have more than enough money to last them a thousand years but they still feel that they need more of it just to survive. They don't give a damn about anyone else but themselves and they feel they deserve to be able to take as much money from anyone they please. None of these people with billions of dollars are doing anything to help people in need. They only spend money to make more money and that's it. And you are dead wrong if you think they won't be coming for yours too. They already are and in time they will get it just because they were taught from an early age that we are living in the greatest country with the perfect system. You believe that you are just like them and you go and promote everything that they stand for. But these people will never stop till they get it all and that means they will drain you of all of your wealth just like they did everybody else's. and when they do, there will be nobody for you to complain to either. So I wouldn't expect a very warm welcome when it's your turn to find a place to sleep at night. LOL Remember that you helped create all of this. This would not be happening at all unless the people here allowed it to happen. We are powerless to fight back when we try to do it alone. We only have power when we unite together and most people today are too busy to care about what is happening to anyone else but themselves. That's why we already lost this war. And if we don't find a way to unite soon, you better expect the worst because you can guarantee that these rich criminals are working day and night to make sure that they get every last penny from you. That is the undisputable facts believe it or not.
@salah3738
2 жыл бұрын
KüHL MITTEL NIEDRIG MOTOR ABS TELLEN What does it mean that I have a Volvo S80?
@brittanywright9646
6 жыл бұрын
Anyone else get annoyed with him taking 10 years to plug the connectors with one hand?? Dude, no one cares about missing the part of you plugging it in. It would've been quicker to just put the camera down or hold the connector with one hand and reach down and plug it in with the other. lol
@mikerainford1969
4 жыл бұрын
Clearly well intentioned, but oh crumbs, what an awful video. Please, put the camera on a stand and prep your shots, that way we are not distracted by stalls over your grass!
@JohnResciniti
5 жыл бұрын
Diagnahs.
@farerse
4 жыл бұрын
diagnosis
@JohnResciniti
4 жыл бұрын
@@farerse thanks! It's been a year, but yeah, don't know what auto correct did there!
@farerse
4 жыл бұрын
@@JohnResciniti well he said it like you wrote it!
@JohnResciniti
4 жыл бұрын
@@farerse oh yeah! That's why I wrote that! I didn't go back an watch the video. It's been so long. I just responded without any knowledge! Oops!
Пікірлер: 79