Reeds. So when the reeds fail the frequency will push back up through the intake ports and back through the carbs. I think its called the helmholtz frequency. Its the reason everyone tried to make those boost bottles that didn't work. Its why reeds are super important on any two stroke.
@shanekerry9530
3 жыл бұрын
My 89 400 Liquid did the same exact thing..... run like a raped ape then fall gut less on its face
@danielbjors8460
3 жыл бұрын
My first thought was fuel pump
@damiendoisher7812
3 жыл бұрын
@@danielbjors8460 be good to check that too.
@aidanhighers8269
3 жыл бұрын
I had a 98 Xc 600 and it would do the same thing and I had to adjust the floats in the cabs to let more fuel in then after I did that now it runs amazing
@GeFeldz
3 жыл бұрын
The 98s and 99s have the Keihin D-slide carbs, and those are SUPER finicky when it comes to float height. EDIT: At least the 600s and 700s have the D-slides.
@donovanwhite2244
3 жыл бұрын
Water sits on the bottom of the tank always. If you tilt the sled so the water is collected in the front corner of the tank, you can just siphon out a small amount instead of the whole tank! Good luck! Love the videos!
@nathanielfischetti7912
3 жыл бұрын
Hell yeah that thing sounds good 👌🏼 my sled blew up today crank is destroyed
@scottivie9428
3 жыл бұрын
I have a ska 440 and I had to replace all the gas lines including the 1in the tank make sure that you use clean line a you get it from you dealer. By using the clear lines you can see the air bubbles in the hose good luck it fixed mine
@josephnewburgh8531
Жыл бұрын
Water=KABOOM! BE careful, remove tank rinse completely flush lines, change plugs, report back, good luck nice sled!!!! I have a 94 440 xcr I'm working on.
@charliethorp796
3 жыл бұрын
I had this problem once and it was the little tangs that you can bend in your fuel bowl let your float set up a little higher it’s just running itself out a fuel. Happened to me on a quad and maybe that’s it? Mine acted the exact same way. In the manual there was even a diagram with a sea level chart so you could use it as a template when you bend them out
@lukenelson2153
3 жыл бұрын
Fuel pickup line in the tank, re-sync carbs and start from scratch there. Possibly bad fuel line other then tank? Other than that maybe a ground wire? When you first get on it leaving your house the tail light is flickering some bad, that makes me feel like its electrical. Just some ideas, i know how easy it is to overlook something simple when you've been wrenching on the same sled for so long! Sold the XLT 600 and Ultra 680 by the way, two old triples that went for a good amount. Glad to see that people still like the wedges even in New Brunswick!
@MidnightPolaris800
3 жыл бұрын
I can tell just by listening that the sled isnt shifting out all the way. Either clutching/jetting/valves dirty or a combination of all
@amac0077
3 жыл бұрын
I’m sure you have already checked it but a dirty fuel filter caused similar issues on my xc440
@donovanwhite2244
3 жыл бұрын
One drop of moisture will plug the vent line and give same result! Try to open the gas cap when it's acting up and you'll know for sure! Hope that helps!
@429thunderjet2
3 жыл бұрын
Yup could be tank isn't venting. Vent line plugged, crimped or something.
@josephnewburgh8531
Жыл бұрын
Vent lines can be a blotch! Even one almost but not all the way pinched off, don't ask how I know! Lol
@leejohnston8629
3 жыл бұрын
Great video as always I almost would check the head gaskets what starts to warm up I had a sled that did the same thing I turned out to be the gaskets between the head gasket and a clutch gasket or possibly bad crank but you definitely must will the more than I do how to next video look forward to seeing it
@robertanthony9674
3 жыл бұрын
I think it might be the coils on your stator that make the charge to run your CDI breaking down when they get hot. I have had that happen many times in the past. It could also be a break in one of the wires from the Stator to the CDI but not as likely. If it is the coils breaking down, it will still show spark when you pull the plugs because the pulse coil will make enough juice to make them spark when you pull it over, but not enough to run it at higher rpm. It is easy to be fooled by it because it will show good spark.
@mr.k6136
3 жыл бұрын
There have been a handful of 440s that impressed me glad you have on that rips. I knew from my m.x. backround that reeds are always worth spending some dough on might fix it might not. Anyway she's sounds great so let give her the onions and let her eat.
@nateruh3698
3 жыл бұрын
seems like its running out of fuel check all your lines I use isopropyl for the fuel great video
@josephnewburgh8531
Жыл бұрын
I use the iso heet, ounce to 6 gallons of non oxygen try that.
@theoldermatt2265
3 жыл бұрын
Its def fuel related, filter,pump,pulse line,the line inside the tank,carb vents, etc
@Hockeyfan9884
2 жыл бұрын
those 440 xcr's are very reliable and quick.
@steevestgermain2965
2 жыл бұрын
one of best sled ever made
@thatmodshop7160
3 жыл бұрын
Sweet video.. stiiiiiiiill waiting on the IQR
@AKproXR
3 жыл бұрын
You’ll be waiting for a little while. To many other sleds to work on to even think about the iqr.
@nathanlacosse2908
3 жыл бұрын
I have an identical problem with my iqr it was the needle and seat
@samueladams1812
3 жыл бұрын
I had that problem with my 94 indy and it was the ignition coil
@AKproXR
3 жыл бұрын
Iv already swapped cdi’s. Not the problem.
@keaghangallant3290
3 жыл бұрын
I have a 1997 440 one of the purple ones It does the same thing constantly it was water I actually had the same problem most of the day The old Polaris gas tanks always gave me a problem with condensation
@caterpillar6nz310
2 жыл бұрын
1998 xcr 440 best sled ever in wedge body
@Bowknows
3 жыл бұрын
Fillin the base maybe. I have a 440 aswell 1993 though no exhaust vlvs Filled the base alot now with proper sync of carbs good to go What it was at full throttle 1 slide was not up all the way adjusted them and now runs excellent
@lesterburritt2038
3 жыл бұрын
Love the videos man. I road with my cousin that had one the quick as hell in the trails . Hope u figure it out. Check the safety switch
@Jtk-qz6uq
3 жыл бұрын
Need some good cleaning the carbs and the jetting and should be good for there
@AKproXR
3 жыл бұрын
Carbs are spotless. Iv been through them multiple times. I have countless hours working on this, that I don’t take video of. I only post a very small amount of what I do on here, lol
@betheleskimo9680
3 жыл бұрын
Maybe it could be the throttle safety switch sticking?
@lesterburritt2038
3 жыл бұрын
I was thinking the same thing.
@gradybeaty416
3 жыл бұрын
Got a question.....a long time you use to build mountain sleds.....why not any more? Just wondering is all..love your videos....helps me trouble shoot a lot.....
@AKproXR
3 жыл бұрын
My riding group fell apart, and quite frankly I was bored of mountain riding.
@ripsaw5003
3 жыл бұрын
She sounds amazing.. but sometimes not all there when u put it to the bar.. reeds or ves valves? How's the 700? I can't wait to see it back up and running again.
@Italian_man11
3 жыл бұрын
Your spark sounds like your issue. If you said you had water in your gas, there’s a good chance you need to clean or replace your plugs. Even a simple regap will go a long ways. I’m a mechanic so if you need any tips just message me.
@thatchernelson3762
2 жыл бұрын
I had a 92 xcr 440, it did the same thing before it went up in flames
@jeffnicks2128
3 жыл бұрын
i use seafoam it seams to work well also try replacing the stator and coil check the tps have a good one
@craiga9492
3 жыл бұрын
I vote Reeds or cracked plug porcelain. Try flipping the petals on the cages maybe
@lloydoxereok1215
4 ай бұрын
Hey,mister Akproxr youtube creator. , are ya selling any late 90s Polaris snogos for an AK N8ve to own. These rigs are die hard, compared to recent models . I love in the boonies part of rural AK. I desperately need a reliable beater heater of Polaris 90s era.
@benjaminderousse3297
3 ай бұрын
Loose snow there bud? I Don't know
@thecoyotehunter9989
3 жыл бұрын
Run some sea foam through it and a fresh tank of gas And also instead of running BR9ES plugs put a set BR8ES plugs they are a little bit of a hotter plug and will make it run better and I can assure you it will run a lot better.
@scotttaylor9339
3 жыл бұрын
That thing sounds like it's jetted perfectly but it's definitely not rich by any means try adjusting floats give it a little more fuel
@powersports4u736
Жыл бұрын
I'm seeing a lot of good guesses. Maybe the fuel pickup line could also be the culprit. Did you ever get it squared away?
@sorensoneric83
3 жыл бұрын
What do your plugs look like after a pull when it starts breaking up
@richardgooden8295
2 жыл бұрын
Those r nice with 1999 xc 700 motor in it handle nice
@jhanrahan13
3 жыл бұрын
i had same problem with my 1999 500 xc ended up being wire broke in the stator
@davidbrennan5
3 жыл бұрын
Without the airbox your jetting and needle position will be way off. It will lose quite a bit of power that way because it sucks warm air from under the hood. You could adjust the carbs to run like that but your leaving HP on the table. I would rebuild the fuel pump, replace the reed petals, install new carb boots rebuild the carbs (set float level) and find the proper airbox for that sled. I would then do plug chops at full throttle and at half throttle if you plugs are black lower your needles at full throttle if your plugs are black install a smaller main jet. 1/4 throttle is adjusted with the screws on the carb and they both need to be set the same or carbs will not be synced use a small drill bit to set the slides so they open at the same time when your at idle .
@AKproXR
3 жыл бұрын
What? Iv never rode this sled without an air box...?
@davidbrennan5
3 жыл бұрын
my bad saw it off but then back on at 12:53 must have missed that, those XCR 440 were one of the the best trail sleds you could get back then. I think that was the first engine Polaris put VES on in 1998. I had one, had to rejet every time the temp changed or it didn't run perfect. I ran the vent lines into the airbox, it made jetting easier. If you like to tinker with jetting and clutching they are fun.
@douglasmaggione9138
3 жыл бұрын
Sounds like it’s overheating. Could be head gasket
@Ronathon02
3 жыл бұрын
Mine had a similar issue. Ended up selling it buyer said One of the cylinders were fucked even though it was randomly running amazing then next thing you know I stop to cross a road and thing bogs down and almost dies multiple times in the middle of the road. I guess I was ripping it like that for 2 years aha only got $300, probably got lied to but I’m no mechanic. thing was absolutely clapped anyways very fun ditchbanger forsure.
@rhyno5228
3 жыл бұрын
Some trail ride content! You have the lakes figured out.
@AKproXR
3 жыл бұрын
Have to get the sleds working before they can make it to a trail...
@jamesthomson9065
3 жыл бұрын
Did you check you fuel pickup in the tank? My friends sled had a crack in the line that let air in from time to time and revealed itself on long pulls and hills.
@benjaminderousse3297
3 ай бұрын
So you ride a red rocket? Dog person? I own an out of date snowmobile that's red and is a 440. They are no longer in production. They were fast compared to snowshoes.
@logantucker9997
3 жыл бұрын
I had a similar problem and it was the fuel filter
@Powerstroke-gc3em
3 жыл бұрын
Stator? I’ve seen them act pretty weird when stator is going out. Or sucking air somewhere?
@tristanburke2451
3 жыл бұрын
If you read the back of a bottle of heat it says for four cycle engines only at least that's what the yellow bottles say don't know if there's any other kind seafoam it's better for snowmobiles
@AKproXR
3 жыл бұрын
Lol. Have a red bottle of iso-heet in my hand as I type. “Use in ALL engines, including 2-cycle or Diesel engines” never use a yellow bottle.
@429thunderjet2
3 жыл бұрын
Yup iso. you should crack the gas tank cap n see if there is a vacuum. Tank vent could be plugged Sea snot won't do anything for water.
@429thunderjet2
3 жыл бұрын
It sounds like it's running out of fuel maybe?
@AlaskaPirates
3 жыл бұрын
Great video
@hommyy-c5494
3 жыл бұрын
dang shes cool hope you win a lot of race with her but will you make some video of your storm swap ultra its been in my head since you talked about it haha i want to see how the engine is mounted im building an xlt swapped storm 800 ans i want to steal some of your tricks haha keep up with the great content 🤟🏻
@AKproXR
3 жыл бұрын
That storm/ultra abomination belongs in the dump. Not sure why people are so fascinated by it. It’s a blown up, cobbled together half parted out sled.
@hommyy-c5494
3 жыл бұрын
@@AKproXR oh.. well we never could’ve known that because you never showed it anyway when is the next triple project?
@emanuelcharbonneau1395
3 жыл бұрын
Check you fuel pickup in the tank
@richardgooden8295
2 жыл бұрын
That sounds nice
@jimbob7072
3 жыл бұрын
I have a 98 red rocket nothing but power valve issues
@AKproXR
3 жыл бұрын
I don’t intend on keeping this one a 440. 🤫
@jimbob7072
3 жыл бұрын
@@AKproXR haha my 00 snopro i made it into a 700 thing is a beast
@edwardneveau5775
3 жыл бұрын
Bad cdi from experience when a bad cdi is cold it wont work when there warm it does but hard to say
@AKproXR
3 жыл бұрын
Iv already swapped cdi’s. Iv done all the normal basic stuff.
@paulcondie2520
3 жыл бұрын
Sucking air in one of fuel lines?
@thatmodshop7160
3 жыл бұрын
@AKproXR flush tank new filter and lines check all seals freshen carbs with kits new plugs. And I know its hard to do but have you tried diagnosing for electrical could be a bad coil or stator might be dirty? When was last time power valves were pulled? Also the way its cutting out sounds in and out maybe broken wire or bad ground?
@mscott594
3 жыл бұрын
I want to agree with you, but at the same time I feel like it's possible that maybe the fuel pump needs to be rebuilt? I originally thought clutching, but seems like a fuel delivery issue.
@thatmodshop7160
3 жыл бұрын
Fuel pump!! Friggen things I had 2 fail on me yeah diaphragm rebuilt kit is cheap and new pump at dealership on $60
@thatmodshop7160
3 жыл бұрын
@@mscott594 😎😎👍👍
@DIPSTICKTV
Жыл бұрын
What years are actually considered “Red Rockets”? 97 and 98?
@AKproXR
Жыл бұрын
Generally speaking that is what most consider a red rocket. Others will also include the 99 xcr 440 (non sp) as it is virtually the same sled with different body work.
@DIPSTICKTV
Жыл бұрын
@@AKproXR is there any differences in the motor from 97 to 98? Or 99 for that matter as well? Someone was telling me that 97 was the actual “red rocket” because of the motor and they changed something in 98. I just don’t know enough about them. Figured I would ask you since I know you’re well rounded in the older Polaris sleds. Would be awesome to add one to the collection down the road though.
@AKproXR
Жыл бұрын
@@DIPSTICKTV 97 xcr 440 engines belonged in the dumpster. They couldn’t get them to hold together and most blew up with short life expectancies. Whole short blocks were replaced in the 97’s with the updated engines found in the 98-99’s by Polaris.
@DIPSTICKTV
Жыл бұрын
@@AKproXR 98 it is lol. Thank you for the info. Hope to ride together someday despite the ridiculous distance between each other.
@richpawlak8432
3 жыл бұрын
I have a xlt 600 95. Can I adjust the chain with the cover on. Give me some tips.
@mitchelpudil3571
3 жыл бұрын
No you’re going to Want to take the cover off to adjust it
@big_whiskey1387
3 жыл бұрын
Fun hobby though 😀
@jeffreyhowes7397
3 жыл бұрын
Love me some red rocket power lol
@jbabister
3 жыл бұрын
u gotta be doin something wrong... how do u have so many problems with every sled u rebuild? i have the same sled rebuilt once 4 years ago and never had a problem since...rebuilt the entire top end with new parts... new parts does pay off..some may not agree but i rebuilt mine with new parts and still runs today like a brand new engine
@AKproXR
3 жыл бұрын
Rebuild? I didn’t rebuild this sled. It’s a $400 beater.
@jbabister
3 жыл бұрын
@@AKproXR its actually not a bad sled... at least for me.... i can lean back crack it about half throttle and pull the ski's a foot off the ground.... alls i did was replace the sleeves and pistons... put a new set of reeds in it and cleaned out the carbs.... she is a nice weapon...surprises people with how snappy it is...
@AKproXR
3 жыл бұрын
If you pick the skis up a foot at half throttle, your setup has far to much weight transfer.
@jackfulton6696
3 жыл бұрын
Would you prefer the 440 over the 700 on a race like you did before? I know it isn't as fast but do you think it would handle better in the turns?
@AKproXR
3 жыл бұрын
The 440 on a short run course like we had is far better. It’s noticeably lighter, the way it’s setup it handles better (same changes could be made to the 700) the big thing is, the 440 won’t wear someone out like my 700 would. It legitimately takes a lot out of someone to hang onto a sled like that for 10 min + pushing it hard.
@AKproXR
3 жыл бұрын
HOWEVER! If there were more long straights, the 700 would dominate.
@danielpomeroy
10 ай бұрын
You're absolutely right about the lightness of your 440 over the 700. On a winding trail they're are blast and they don't wear you out. Too busy grinning. Lol.
@danielpomeroy
10 ай бұрын
Wish polaris would put an updated 440 liquid in the new sleds
@thesenutz77
3 жыл бұрын
See the tail light flickering with idle?
@Ethan-ck6iz
3 жыл бұрын
It's just the video
@portergehrke7393
3 жыл бұрын
Cool
@chadmiller1120
3 жыл бұрын
Holy shat I’m #20! Somebody get me a shot !
@shperax
3 жыл бұрын
Needs proper maintenance. It's hardly ever water that's the issue. That's just wishful thinking
@AKproXR
3 жыл бұрын
Perfect, tell me what’s wrong with it then. Thanks.
@shperax
3 жыл бұрын
@@AKproXR check compression but. my 1st thought with these symptoms is check your fuel pressure. Pumps are cheap. If you have the hoses off the carbs, gas should spray out at least 3 inches when you pull the engine over. If it just trickles out get a new pump. Bad compression can also cause this since they work off vacuum on the lower end. Did you check the carb fuel intake screens. Did you check your gas tank fuel filter. Those may be clogged. Kinked vacuum or fuel lines. Old cracked vacuum lines. Just some of the more common things I've seen on these sleds.
@edmondkoe9132
3 жыл бұрын
Change the coils bud u be fine
@AKproXR
3 жыл бұрын
Been there, done that. Bo difference. I put countless hours into working on these off camera. Lol
@russellhuston6481
7 ай бұрын
Id bet ur fuel pump is full of jelloee fuel. Open it and inspect it.
@richardgooden8295
2 жыл бұрын
Sounds Lil lean
@tr4415
2 жыл бұрын
I don't see anything wrong with that
@SwampDonkey530
3 жыл бұрын
Try some 100LL and some sea foam 👍
@benjaminderousse3297
3 ай бұрын
😂
@ntivemomspridendjoy5080
3 жыл бұрын
First view yea buddy!
@gradybeaty416
3 жыл бұрын
She's a screamer..
@77Zach
3 жыл бұрын
that thing looks slow as shit
@AKproXR
3 жыл бұрын
All 440’s are slow as shit in loose snow like that. It is, however one of the slowest sleds I own. I was never a big fan of 440’s, but people seem to love them and think they are faster then they are. I just like how they look LOL.
@77Zach
3 жыл бұрын
@@AKproXR im not hating on the sled it sounds and looks like its not very happy at point but when it wakes up it moves out but all that on average from this video of it my 91 indy 500 fuji would smoke this
@big_whiskey1387
3 жыл бұрын
I just like how you have all these sleds and none of em run perfectly! There all basically turds 💩 and part sleds...
Пікірлер: 131