My 950 had similar problems. Took a 9 mm cleaning bore brush and pulled out lots of gunk and growth. Rinsed for a long time with kerosene and used long handle air conditioner/heat pump cleaning brushes from the cap down and drain up. Replaced fuel hose to filter and went through 2 fuel filters in last 25 hours. Runs great now with some fuel cleaners & conditioners added.
@lefthandedleprechaun8702
Жыл бұрын
I see this a lot on tractors that the owners fuel with small cans, open cans ,dirty funnels, never capped, loaded with debris from just sitting around, not strained or filtered between the can and fuel tank. Bugs, dirt dobbers, mud nests, spiders, etc.
@markfertonani3945
Ай бұрын
I have a 2320 mini tractor and i took my tank out clean it and it was fine for awhile then i had the same thing happen again so now i just shoot some compressed air through the vent tube and its fine.for a bit
@rodneybrown3137
5 жыл бұрын
Find out if there is a micro fuel strainer (sock) inside the fuel tank. I have a 1994 Ford/New Holland and after weeks of diagnosis it turned out to be the strainer in the tank choking down the fuel flow. This is similar to the affect of having a bad fuel cap not ventilating. I cleaned mine and re-installed it, in hind sight wish I took it off completely and allowed the primary filter to catch the trash . . easier to change.
@jonathanhandsmusic
5 жыл бұрын
Having similar problem on my old jd 1050. After replacing fuel filter & housing, injection pump, still doing it. Mechanic at shop 50 miles from here said to unscrew fuel cap after starting and see what happened. It ran a lot better for 10 minutes then quit. Gonna try what you did. Gotta feeling theres gunk in the fuel outflow fitting. Thanks for posting!
@mikemondrik2041
2 жыл бұрын
Thanks I had a good idea of checks to do this 5065E had strainer in the tank I could blow through fine but fuel would trickle. Found strainer after watching video
@augustinhernandez1581
2 жыл бұрын
Outstanding thank you for the information
@glynnj4482
5 жыл бұрын
Video is too slow on my poor internet service from Verizon, but I will tell you about my issue on a JD 5105. Starving for fuel. Changed filter no fix. Full flow from fitting on tank. Traced line and found an inline filter at the back of the engine (end of the valve cover) out of sight. Had to remove the hood to get access.
@concert610
6 жыл бұрын
I have an issue with my J.D 5050D. After using the tractor for 30 minutes or so it's starved for fuel. After a break the tractor runs fine. I replaced the fuel filter, and bleed the lines. I will have to take it this next step. I had expected water in the tank to been the problem in the beginning. Thank you for the new idea. A blockage in the fuel line makes sense.
@sbirdranch
6 жыл бұрын
My 990 has two filters as well. The one in the video near the back is a strainer basket type. I have another under the hood cowling that is a canister type. Funny after 30 minutes. That sounds like a heat related thing. Good luck.
@concert610
6 жыл бұрын
Thanks. I was worried that it might be head gasket related. Coolant gets hot. Thermostat opens. Water gets into cylinders. I think the water was in the fuel/water filter. Before replacing the fuel filter it would blow white/gray smoke when it was running low on power during high rpm use.
@concert610
6 жыл бұрын
I pulled the fuel like and found very low flow. So I took off the fuel valve and there was a fuel filter on it. Very very dirty. Makes me wonder just how often this gets people.
@jeffpalmer5534
6 жыл бұрын
How did you fix it
@ChrisSmith-fp1tw
5 жыл бұрын
Thanks for sharing. Helped me out with my JD 2130.
@Marine-iu3ev
11 ай бұрын
Diesel fuel is dirty. I always filter fuel from the pump into the tractor fuel tank and makes a big difference. Give it a try.
@johnflynn3089
Жыл бұрын
I think I’ve got a bad fuel filter casing up top going to fuel pump Tried running a wire, clean it out still does not flow
@majorjujo
12 жыл бұрын
what that thing that you pulled out of the fitting is just slug from the diesel fule. what you can do prevent that is to put diesel fuel treatment in it. i have 2 990 and that is the main problem with em
@robertdelisle2412
Жыл бұрын
Check the filter in the tank
@johnflynn3089
Жыл бұрын
Wish my problem was that simple
@hunter6099
3 жыл бұрын
Was it blowing black smoke?
@Ugot2BkddnMe
3 жыл бұрын
3032e just died. Sounded like it ran out of fuel but I know that's not the case. Time to go look for signs of "gunk".
@sbirdranch
3 жыл бұрын
I recently blew a wad of gunk out of the line between the rear and forward fuel filters. Read the comments. Recently someone turned me on to a product for killing the bacteria that grows this stuff. After doing some research, it is probably that my problem is starting in my outdoor fuel storage. Good luck. ~P
@Ugot2BkddnMe
3 жыл бұрын
@@sbirdranch I was able to isolate the issue to the fuel filter and not the water separator. The "gunk" had accumulated in the filter in such a manner that it wasn't a slow choke off of fuel but a complete shut off. New fuel filter, several (15-20) times of flipping the ignition key on and off (per instructions from the Service Mgr @ the Deere...lership) and BINGO! Houston, we have liftoff.
@cooltee01
7 жыл бұрын
Thanks this video was helpful
@sbirdranch
7 жыл бұрын
Glad it helped. Your welcome.
@johnflynn3089
Жыл бұрын
Basic ,need to secondary filter to injector pump
@martosimartinov4511
2 жыл бұрын
hi, know its been a while since u post, but i have problem with my d1350fd , just start smoking white like crazy , working for a while and shut down, trun on again wokring for a while and again and again ,any advice i would apreciate .
@dapetik
3 ай бұрын
Did you have luck figuring out the problem. Mine does A similar thing where it starts spewing out smoke and losing power. After a few seconds, it clears up and continues as normal
@That_Teal_fummins
9 жыл бұрын
I need some help I have a 2007 990 and it will oby rev up to 2200rpm the spits and spews white smoke. Air filters clean could this be the problem
@sbirdranch
9 жыл бұрын
What you are describing is a fuel problem. If the comments below from Luke are correct then this could happen to any of the diesel tractors. I would start by checking the rear fuel filter as shown in the video. If that runs good, check the filter up by the motor under the right hand motor skirt. If that filter looks good, remove the line and make sure the fuel is flowing. A rubber line can become plugged on its own.
@That_Teal_fummins
9 жыл бұрын
sbirdranch it was the main fuel filter on the engine works great now had 545 hours on it
@ChrisSmith-fp1tw
5 жыл бұрын
Sounds like there is trash in fitting on the bottom of the tank. Mine was doing the same thing and I ran a piece of wire up in it. Fuel flow was better and it ran good after that.
Пікірлер: 33